TOCCO Gets Conditional Pass on Health Inspection - Chicago Restaurant

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: OBSERVED NO WRITTEN EMPLOYEE HEALTH POLICY ON THE PREMISES. MANAGEMENT INSTRUCTED TO PROVIDE A SIGNED EMPLOYEE HEALTH POLICY FOR EACH EMPLOYEE. PRIORITY FOUNDATION 7-38-010. NO CITATION ISSUED. - -

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: OBSERVED NO CLEAN UP PROCEDURE ON THE PREMISES FOR VOMIT AND DIARRHEAL EVENTS. MANAGEMENT INSTRUCTED TO PROVIDE A CLEAN UP PROCEDURE AND SUPPLIES. PRIORITY FOUNDATION 7-38-005. NO CITATION ISSUED.

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

FOOD-CONTACT SURFACES: CLEANED & SANITIZED - Comments: FOUND THE KITCHEN LOW TEMPERATURE DISH MACHINE IN USE NOT ADEQUATELY SANITIZING FOOD EQUIPMENTS,UTENSILS "CHEMICAL 0 PPM". INSTRUCTED MANAGER TO REPAIR DISH MACHINE AND MAINTAIN SANITIZER AT 100 PPM. DISH MACHINE IS TAGGED HELD FOR INSPECTION AND MUST NOT BE USED UNTIL RE-INSPECTED BY CHICAGO DEPARTMENT OF HEALTH. INSTRUCTED MANAGER TO USE THREE COMPARTMENT SINK TO PROPERLY WASH, RINSE, AND SANITIZE FOOD EQUIPMENT AND UTENSILS ETC.MANAGEMENT IMMEDIATELY CALLED SERVICE FOR DISHWASHER AT THIS TIME. PRIORITY VIOLATION 7-38-025.CITATION ISSUED. - COS

Dirty equipment harbors and spreads pathogens, causing cross-contamination and illness.

All food contact surfaces must be properly cleaned and sanitized.

Wash, rinse, sanitize after each use; Clean between different raw foods; Every 4 hours for continuous use; When contaminated; Proper procedures and chemicals.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED TORN GASKET AT FRONT PIZZA PREP COOLER RIGHT BOTTOM DOOR AND RUSTS ON EXTERIOR OF GREASE TRAP BOX DISHWASHING AREA.INSTRUCTED TO REPLACE TORN GASKETS AND REMOVE RUSTS AT GREASE TRAP BOX AND MAINTAIN.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED WORNED-OUT COLORED CODED CUTTING BOARDS.INSTRUCTED TO REPLACE COLORED CODED CUTTING BOARDS AND MAINTAIN.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: DETAIL CLEAN GASKETS AT COOLERS IN FOOD PREP AREAS,FOOD PREP SHELVINGS THROUGHOUT,EXTERIOR SURFACES OF KITCHEN DISHMACHINE,WALK-IN-COOLER SHELF.

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: Backflow preventer not located at coffee expresso unit in bar area.Instructed to install so that it can be located to be serviced and maintained.

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: INSTRUCTED TO DETAIL CLEAN AND REMOVE DUSTS FROM FAN COVERS IN WALK-IN-COOLER AND MAINTAIN.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED CLUTTERED CONDITIONS NEAR THE GREASE TRAP BOX IN REAR PREP/DISHWASHING AREAS AND UNUSED EQUIPMENTS.INSTRUCTED TO DETAIL CLEAN AND ORGANIZE AND REMOVE UNECESSARY EQUIPMENTS,ITEMS AND MAINTAIN.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED DUST ACCUMULATIONS AT CORNER WALL NEAR THE FRONT PREP PIZZA OVEN.INSTRUCTED TO DETAIL CLEAN WALLS AND MAINTAIN.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: INSTRUCTED TO REMOVE DUSTS ACCUMULATIONS AT HOOD ABOVE THE KITCHEN DISHMACHINE AND TO MAINTAIN.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: INSTRUCTED TO REMOVE DUSTS ACCUMULATIONS AT HOOD ABOVE THE KITCHEN DISHMACHINE AND TO MAINTAIN.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.