SUBWAY Fails Health Inspection - Chicago Restaurant

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: NO EMPLOYEE HEALTH POLICY ON SITE. MUST PROVIDE PRIORITY FOUNDATION VIOLATION#: 7-38-010. NO CITATION ISSUED.

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: NO VOMITOUS AND DIARRHEAL INCIDENT CLEAN UP POLICY AND KIT ON SITE. MUST PROVIDE. PRIORITY FOUNDATION VIOLATION#: 7-38-005. NO CITATION ISSUED.

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

FOOD-CONTACT SURFACES: CLEANED & SANITIZED - Comments: OBSERVED EMPLOYEE AT THE THREE COMPARTMENT SINK WASH DIRTY DISHES WITH SOAP, THEN RINSE DISHES, AND PROCEED TO STORE THEM AWAY ON THE DRYING RACK. MUST SANITIZE ALL COOKWARE AND UTENSILS AT THE 3 COMPARTMENT SINK IN A SANITIZING SOLUTION AFTER RINSING TO PROVIDE ADEQUATE SANITATION. FACILITY HAS CORRECTED VIOLATION ON SITE BY INSTRUCTING EMPLOYEES ON PROPER WASH/RISE/SANITIZE PROCEDURES. PRIORITY VIOLATION#: 7-38-005. CITATION ISSUED.

Dirty equipment harbors and spreads pathogens, causing cross-contamination and illness.

All food contact surfaces must be properly cleaned and sanitized.

Wash, rinse, sanitize after each use; Clean between different raw foods; Every 4 hours for continuous use; When contaminated; Proper procedures and chemicals.

This violation was corrected during the inspection.

THERMOMETERS PROVIDED & ACCURATE - Comments: MUST PROVIDE THERMOMETERS TO BE CONSPICUOUS AND EASILY VISIBLE INSIDE ALL COOLERS.

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED CARDBOARD BEING USED AS SHELF LINER IN THE DRY STORAGE AREA AND THE WALK IN COOLER. MUST REMOVE AND PROVIDE SHELF LINING THAT IS A NON-ABSORBENT, NON-CORROSIVE, SMOOTH, EASILY CLEANABLE MATERIAL.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: OBSERVED THE 3 COMPARTMENT SINK UNABLE TO PROVIDE ADEQUATE DISH WASHING/RINSING/SANITIZING AT TIME OF INSPECTION. OBSERVED WHEN ONE COMPARTMENT IS DRAINED THE WATER BACKS UP BACK INTO THE ADJACENT COMPARTMENTS. MUST REPAIR AND MAINTAIN. PRIORITY FOUNDATION VIOLATION#:7-38-025. CITATION ISSUED.

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: OBSERVED NO TEST STRIPS ON SITE TO PROVIDE ADEQUATE TESTING OF SANITIZING SOLUTION CONCENTRATION LEVELS IN THE 3 COMPARTMENT SINK. MUST PROVIDE. PRIORITY FOUNDATION VIOLATION#:7-38-005. SEE ABOVE VIOLATION FOR CITATION.

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: OBSERVED A SLIGHT LEAK AT THE PIPE AT THE BOTTOM OF THE THREE COMPARTMENT SINK. MUST REPAIR AND MAINTAIN.

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED THE CAULKING AROUND THE THREE COMPARTMENT SINK IN POOR REPAIR. MUST RE-CAULK AND MAINTAIN.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED AN EXCESSIVE AMOUNT OF DIRT/FOOD DEBRIS BUILDUP IN BETWEEN THE COOLERS/CABINETS IN THE FRONT PREP AREA. OBSERVED AN ACCUMULATION OF EXCESS FOOD DEBRIS ON THE FLOOR AROUND THE GREASE TRAP. MUST DETAIL CLEAN AND MAINTAIN.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: OBSERVED AN ACCUMULATION OF DIRT/DEBRIS BUILDUP ON THE TOILET ROOM EXHAUST VENTILATION. MUST DETAIL CLEAN AND MAINTAIN.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: OBSERVED AN ACCUMULATION OF DIRT/DEBRIS BUILDUP ON THE TOILET ROOM EXHAUST VENTILATION. MUST DETAIL CLEAN AND MAINTAIN.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.