REDZ BELIZEAN RESTAURANT LLC Fails Health Inspection - Chicago Restaurant

DISH MACHINES: PROVIDED WITH ACCURATE THERMOMETERS, CHEMICAL TEST KITS AND SUITABLE GAUGE COCK - Comments: NO CHEMICAL TEST KIT ONSITE. INSTRUCTED ON LAST INSP. DATED 6/18/2015 TO MAINTAIN TEST KIT ON-SITE. SERIOUS VIOLATION 7-38-030.

Temperatures below 135°F allow bacteria to multiply, especially spore-formers that survive cooking.

Hot foods must be held at 135°F or above.

Maintain 135°F or above; Check temperatures regularly; Proper hot holding equipment; Cannot reheat in hot holding units.

FOOD IN ORIGINAL CONTAINER, PROPERLY LABELED: CUSTOMER ADVISORY POSTED AS NEEDED - Comments: OBSERVED BULK FOOD OUT OF ORGINAL CONTAINERS NOT LABELED; DESSERTS, BREADS AND SOUP. INSTRUCTED TO LABEL FOODS AND MAINTAIN.

Improper methods result in slow cooling that allows bacterial growth.

Approved cooling methods must be used.

Use shallow pans, ice baths, rapid chill units, ice wands; Cut large items into smaller portions; Stir frequently; Leave uncovered during cooling.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: OBSERVED BROKEN DOOR GASKETS ON BOTH 2-DOOR COOLERS IN PREP AREA, AND ON THE DEEP FREEZER BEHIND THE FRONT CUSTOMER COUNTER. ALSO, RUST, GREASE BUILD UP, AND DEBRIS ON STORAGE RACKS THROUGHOUT THE KITCHEN. INSTRUCTED TO REPAIR OR REPLACE GASKETS, AND CLEAN RACKS SO THEY ARE SMOOTH AND EASILY CLEANABLE AND MAINTAIN.

Unapproved processes may lack critical safety controls.

Variance required before conducting specialized food processes.

Submit application to CDPH; Include HACCP plan; Await approval before starting; Maintain all required records.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: OBSERVED FOOD DEBRIS ON THE FOLLOWING FOOD AND NON FOOD CONTACT EQUIPMENT; MIXER, LOWER SHELF ON PREP TABLES, STOVE, FRYER, INTERIOR/EXTERIOR OF ICE MACHINE. INSTRUCTED TO CLEAN, SANITIZE AND MAINTAIN.

Dirty equipment harbors bacteria and attracts pests.

All equipment and utensils must be clean and properly maintained.

Equipment clean to sight and touch; Free of food debris and grease; Maintained in good repair; Stored properly when clean.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: OBSERVED DIRTY FLOORS IN THE FOLLOWING AREAS; UNDER HEAVY EQUIPMENT IN KITCHEN, MOP ROOM, AND TOILET ROOM. INSTRUCTED TO CLEAN AND MAINTAIN.

Damaged floors harbor bacteria and create safety hazards.

Floors must be smooth, cleanable, and maintained.

Smooth, non-porous in food areas; Properly sloped to drains; Coving at wall junctures; Kept clean; Good repair.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: OBSERVED STAINED CEILING TILE IN THE STAFF TOILET ROOM AND CUSTOMER SEATING AREA. DUST BUILD-UP ON THE WALL AND CEILING VENT COVERS IN REAR PREP. INSTRUCTED TO REPAIR, CLEAN AND MAINTAIN.

Damaged surfaces cannot be properly cleaned and may harbor pests.

Walls and ceilings must be smooth, cleanable, and in good repair.

Smooth, washable surfaces in food areas; Light colored; No holes or cracks; Clean and maintained.

LIGHTING: REQUIRED MINIMUM FOOT-CANDLES OF LIGHT PROVIDED, FIXTURES SHIELDED - Comments: MISSING LIGHTS IN STAFF TOILET ROOM, INSTRUCTED TO REPLACE AND MAINTAIN.

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

PREMISES MAINTAINED FREE OF LITTER, UNNECESSARY ARTICLES, CLEANING EQUIPMENT PROPERLY STORED - Comments: OBSERVED EXCESSIVE CLUTTER IN THE FURNACE ROOM. INSTRUCTED TO REMOVE ITEMS SIX INCHES OFF FLOORS TO PREVENT RODENT HARBORAGE AND MAINTAIN.

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.

PREMISES MAINTAINED FREE OF LITTER, UNNECESSARY ARTICLES, CLEANING EQUIPMENT PROPERLY STORED - Comments: OBSERVED EXCESSIVE CLUTTER IN THE FURNACE ROOM. INSTRUCTED TO REMOVE ITEMS SIX INCHES OFF FLOORS TO PREVENT RODENT HARBORAGE AND MAINTAIN.

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.