NHU LAN BAKERY Fails Health Inspection - Chicago Bakery

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: OBSERVED CLEAN-UP OF VOMITING AND DIARRHEA PROCEDURE ON SITE BUT CLEAN-UP KIT ON PREMISES DURING INSPECTION OBSERVED TO BE BLOOD BORNE PATHOGEN CLEAN UP KIT WITH OUT PROPER SANITIZING SOLUTION AND NO MOP FOR VOMIT CLEAN UP . INSTRUCTED TO HAVE SAID PROCEDURE ALONG WITH REQUIRED EQUIPMENT FOR CLEAN-UP. PRIORITY FOUNDATION VIOLATION. NO CITATION ISSUED. 7-38-005

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

PROPER DATE MARKING AND DISPOSITION - Comments: OBSERVED READY TO EAT, TEMPERATURE CONTROL FOR SAFETY FOODS (SOUPS,COOKED PORK MEAT, COOKED TOFU)NOT PROPERLY DATED , STORED LONGER THAN 24 HOURS IN COOLERS. INSTRUCTED TO PROVIDE PROPER DATE MARKING WITH DISPOSITION DATE FOR RTE FOODS PREPARED ON SITE AND HELD OVER 24 HOURS IN COLD HOLDING UNIT. PRIORITY FOUNDATION VIOLATION. 7-38-005 CITATION ISSUED.

Inadequate reheating fails to kill bacteria that grew during storage.

Foods must be reheated to 165°F within 2 hours.

Reheat to 165°F within 2 hours; Use proper equipment (not hot holding units); Discard if not reaching temperature in time.

THERMOMETERS PROVIDED & ACCURATE - Comments: MUST PUT PROPERLY WORKING THERMOMETERS INSIDE HOT HOLDING UNIT CONSPICUOUSLY POSTED TO MONITOR THE AMBIENT TEMPERATURE OF EQUIPMENT. INSTRUCTED TO PROVIDE ACCURATE AMBIEN MEASURING THERMOMETERS

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

FOOD PROPERLY LABELED; ORIGINAL CONTAINER - Comments: OBSERVED INCOMPLETE FOOD LABEL ON PREPACKED FOOD ITEMS STORED FOR SALE IN DISPLAY COOLER. MISSING INFORMATION ABOUT THE PRODUCTION BUSINESS. INSTRUCTED MANAGER TO PROVIDE THE COMMON NAME OF THE FOOD, A LIST OF INGREDIENTS; THE NAME AND PLACE OF BUSINESS OF THE MANUFACTURER, PACKER, OR DISTRIBUTOR; AND THE NAME OF THE FOOD SOURCE FOR EACH MAJOR FOOD ALLERGEN CONTAINED IN THE FOOD. INSTRUCTED TO PROVIDE.

Missing allergen labeling can cause severe allergic reactions.

All food properly labeled with required information.

Common name; Ingredients; Allergen declarations; Date marking; Manufacturer info; Net quantity.

INSECTS, RODENTS, & ANIMALS NOT PRESENT - Comments: OBSERVED APPROXIMATELY 25-30 LIVE SMALL FLYING INSECTS AT SITE DURING INSPECTION IN THE FOLLOWING AREAS : IN DISH WASHING AREA 5, IN FRONT FOOD PREP AREA 15,IN REAR STORAGE AREA 7. RECOMMEND CONTACTING PEST CONTROL. PRIORITY FOUNDATION VIOLATION. 7-38-020(A).CITATION ISSUED.

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

CONTAMINATION PREVENTED DURING FOOD PREPARATION, STORAGE & DISPLAY - Comments: FOOD CONTAINERS STORED ON FLOOR IN WALK-IN COOLER/FREEZERS. MUST PROVIDE PROPER, RAISED SHELVING TO STORE FOOD CONTAINERS 6" OFF FLOOR.

Contamination during preparation is a leading cause of foodborne illness.

Prevent contamination during all food handling.

Minimize bare hand contact; Prevent cross-contamination; Use clean equipment; Proper employee hygiene.

PERSONAL CLEANLINESS - Comments: OBSERVED THAT EMPLOYEE WORE BRACELETS ON HANDS WHILE WORKING WITH EXPOSED FOOD.MUST REMOVE ALL JEWELRY EXCEPT PLAIN WEDDING BAND FROM HANDS WHILE WORKING WITH EXPOSED FOOD

Poor personal hygiene transfers contaminants to food.

Food handlers must maintain personal cleanliness.

Clean outer clothing; Hair restraints; Short, clean fingernails; No jewelry except plain ring; Clean hands and arms.

UTENSILS, EQUIPMENT & LINENS: PROPERLY STORED, DRIED, & HANDLED - Comments: OBSERVED THAT SIGNIFICANT AMOUNT OF FOOD PREPARATION DISHES TO BE STORED IN OUTSIDE REAR YARD WITH OUT ANY PROTECTION.MUST PROVIDE PROPER ENVIRONMENTAL PROTECTION FOR ALL DISHES USED FOR FOOD PROTECTION. IF THOSE ITEMS NOT USED IN FACILITY SHOULD BE REMOVED TO PREVENT PEST HARBORAGE.

Clutter harbors pests and prevents proper cleaning.

Facility must be free of unnecessary items and litter.

Remove unnecessary equipment; No litter; Organized storage; No living quarters; Personal items in designated areas.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: NOTED ASSORTED FOOD ITEMS INSIDE COOLERS AND REFRIGERATION UNITS FOOD STORED INSIDE GROCERY BAGS. INSTRUCTED TO PROPERLY STORE ALL FOOD ITEMS INSIDE APPROVED FOOD GRADE CONTAINERS.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED TORN RUBBER GASKET ON DOOR TO 3 DOOR GLASS REACH IN COOLER IN REAR STORAGE AREA . INSTRUCTED TO REPAIR AND/OR REPLACE AND MAINTAIN

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: OBSERVED SMALL LEAK FROM FIRST COMPARTMENT OF THREE COMPARTMENT SINK .MUST REPAIR AND MAINTAIN

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: MUST CLEAN AND MAINTAIN CLEAN FLOORS IN WALK IN FREEZER COVERED WITH ICE AND FOOD DEBRIS

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: MUST CLEAN AND MAINTAIN CLEAN LIGHT SHIELD WITH DEAD INSECTS INSIDE

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: MUST CLEAN AND MAINTAIN CLEAN LIGHT SHIELD WITH DEAD INSECTS INSIDE

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.