BARNEY'S PIZZA Fails Health Inspection - Chicago Restaurant

NO BARE HAND CONTACT WITH RTE FOOD OR A PRE-APPROVED ALTERNATIVE PROCEDURE PROPERLY ALLOWED - Comments: OBSERVED FOOD HANDLER TOUCH READY-TO-EAT FOOD BREAD WITH BARE HANDS WHILE SLICING IT. FOOD EMPLOYEES? MAY NOT CONTACT EXPOSED, READY-TO-EAT FOOD WITH THEIR BARE HANDS. MUST USE SUITABLE UTENSILS SUCH AS DELI TISSUE, SPATULAS, TONGS, SINGLE-USE GLOVES, OR DISPENSING EQUIPMENT. PRIORITY VIOLATION. 7-38-010. CITATION ISSUED.

Contaminated water spreads waterborne diseases. Insufficient hot water prevents proper sanitization.

Potable water supply must be adequate, protected, and properly heated.

Water from approved public system; Sufficient pressure for all operations; Hot water minimum 120°F at fixtures, 180°F for high-temp dishwashers; Backflow prevention installed; No cross-connections.

THERMOMETERS PROVIDED & ACCURATE - Comments: OBSERVED NO FOOD TEMPERATURE MEASURING DEVICE ON SITE AT TIME OF INSPECTION. INSTD TO PROVIDE AND MAINTAIN ON SITE. PRIORITY FOUNDATION 7-38-005.CITATION ISSUED

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

FOOD PROPERLY LABELED; ORIGINAL CONTAINER - Comments: OBSERVED FLOUR OUT OF THE ORIGINAL CONTAINER AND IN STAINLESS STEEL CONTAINER BY THE PREP STATION WITHOUT LABEL CONTAINING THE PRODUCT NAME. INSTRUCTED TO LABEL ALL FOODS AND SPICES WITH COMMON NAME THAT ARE OUT OF THE ORIGINAL CONTAINERS.

Missing allergen labeling can cause severe allergic reactions.

All food properly labeled with required information.

Common name; Ingredients; Allergen declarations; Date marking; Manufacturer info; Net quantity.

WIPING CLOTHS: PROPERLY USED & STORED - Comments: OBSERVED SOILED WIPING CLOTHS STORED ON PREP TABLES. INSTRUCTED MANAGER TO STORE IN SANITIZING SOLUTION BETWEEN USES.

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED CUTTING BOARD ON MAIN COOK LINE COVERED WITH DEEP GROOVES AND DARK STAINS. INSTRUCTED TO REPAIR OR REPLACE AND MAINTAIN SMOOTH, CLEANABLE SURFACES.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: OBSERVED NO CHLORINE OR QUATS SANITIZER TESTING DEVICES ON SITE AT TIME OF INSPECTION. INSTRUCTED TO PROVIDE. PRIORITY FOUNDATION VIOLATION 7-38-005. CITATION ISSUED.

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: OBSERVED UNDER 3 COMPARTMENT SINK NOT CLEAN, WATER STAINED, DEBRIS. INSTD TO CLEAN AND MAINTAIN SAME

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: OBSERVED THE INSIDES OF THE LOWER REACH INS UNDER THE HOT LINE SIDE WITH A BUILD UP OF DIRT, DEBRIS AND OTHER ITEMS. INSTRUCTED TO REMOVE, CLEAN AND MAINTAIN AREA.

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: OBSERVED ACCUMULATED GREASE AND FOOD DEBRIS ON INTERIOR AND EXTERIOR SURFACES OF COOKING EQUIPMENT, PREP TABLES, COOLERS, FREEZERS, SHELVING UNITS. INSTRUCTED MANAGER TO CLEAN AND MAINTAIN.

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: OBSERVED A LEAK AT THE 3 COMPARTMENT SINK. INSTRUCTED MUST REPAIR OR REPLACE LEAKY PIPE AT 3 COMPARTMENT SINK.

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED THE FLOORS UNDER AND AROUND ALL COOKING AND NON COOKING EQUIPMENT WITH A BUILD UP OF DUST, DIRT, GREASE AND DEBRIS. INSTRUCTED TO CLEAN AND MAINTAIN ALL AS A MEANS OF PREVENTING POSSIBLE PEST AND INSECT HARBORING.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED THE FLOORS UNDER AND AROUND ALL COOKING AND NON COOKING EQUIPMENT WITH A BUILD UP OF DUST, DIRT, GREASE AND DEBRIS. INSTRUCTED TO CLEAN AND MAINTAIN ALL AS A MEANS OF PREVENTING POSSIBLE PEST AND INSECT HARBORING.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: OBSERVED DUST ON AND AROUND FILTERS IN THE BATHROOM AND FRONT PREP AREA. MUST CLEAN AND MAINTAIN.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: OBSERVED DUST ON AND AROUND FILTERS IN THE BATHROOM AND FRONT PREP AREA. MUST CLEAN AND MAINTAIN.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.