BARNEY'S PIZZA Fails Health Inspection - Chicago Restaurant

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: NO EMPLOYEE HEALTH POLICY ON SITE AT THE TIME OF INSPECTION. INSTRUCTED TO OBTAIN AND MAINTAIN. PRIORITY FOUNDATION. 7-38-010. NO CITATION ISSUED.

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: NO VOMIT OR DIARRHEA PROCEDURE OR SUPPLIES ON SITE AT TIME OF INSPECTION. INSTRUCTED TO OBTAIN AND MAINTAIN. PRIORITY FOUNDATION. 7-38-005. NO CITATION ISSUED.

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: NO HANDWASHING SIGN IN EMPLOYEE WASHROOM. MUST PROVIDE.

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

PROPER COLD HOLDING TEMPERATURES - Comments: OBSERVED TCS FOODS HELD AT IMPROPER TEMPERATURE INSIDE FRONT PREP COOLER: CHICKEN (48.3F), RIBS (46.8F,44.2F). INSTRUCTED TO DISCARD APPROXIMATELY 2 POUNDS OF FOOD AT A COST OF $6. PRIORITY. 7-38-005. CITATION ISSUED.

Temperatures below 135°F allow bacteria to multiply, especially spore-formers that survive cooking.

Hot foods must be held at 135°F or above.

Maintain 135°F or above; Check temperatures regularly; Proper hot holding equipment; Cannot reheat in hot holding units.

FOOD PROPERLY LABELED; ORIGINAL CONTAINER - Comments: OBSERVED CONTAINERS OF FOOD INGREDIENTS (GARLIC, SUGAR, SALT) WITHOUT LABELS IN REAR PREP AREA. ALL FOODS MUST BE LABELED WITH COMMON NAME UNLESS IN ORIGINAL PACKAGING.

Missing allergen labeling can cause severe allergic reactions.

All food properly labeled with required information.

Common name; Ingredients; Allergen declarations; Date marking; Manufacturer info; Net quantity.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED RUSTED SHELVING UNIT ON RIGHT WALL OF WALK IN COOLER. MUST REPLACE OR REPAINT SHELVING UNIT.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: OBSERVED FOOD RESIDUE AND GREASE INSIDE MICROWAVE IN FRONT PREP AREA. MUST CLEAN AND MAINTAIN.

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

GARBAGE & REFUSE PROPERLY DISPOSED; FACILITIES MAINTAINED - Comments: OBSERVED LITTER SCATTERED THROUGHOUT REFUSE AREA. MUST CLEAN AND MAINTAIN AT ALL TIMES.

Poor waste management attracts pests and creates contamination sources.

Refuse must be properly contained and removed.

Leak-proof, pest-proof containers; Tight-fitting lids; Clean storage areas; Frequent removal; Containers cleaned.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: OBSERVED DUST ON AND AROUND FILTERS IN FRONT PREP AREA. MUST CLEAN AND MAINTAIN.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ALLERGEN TRAINING AS REQUIRED - Comments: OBSERVED NO ALLERGEN CERTIFICATION ON SITE. INSTRUCTED MANAGEMENT TO GET ALLERGEN CERTIFICATION. INSTRUCTED MANAGER TO PROVIDE AND MAINTAIN ALLERGEN TRAINING FOR ALL CITY CERTIFIED MANAGERS AS REQUIRED.

Inadequate allergen knowledge can cause life-threatening allergic reactions.

Food allergen training required for certified managers.

Certified managers must complete allergen training; Staff must understand major allergens; Prevent cross-contact; Respond to customer inquiries.

ALLERGEN TRAINING AS REQUIRED - Comments: OBSERVED NO ALLERGEN CERTIFICATION ON SITE. INSTRUCTED MANAGEMENT TO GET ALLERGEN CERTIFICATION. INSTRUCTED MANAGER TO PROVIDE AND MAINTAIN ALLERGEN TRAINING FOR ALL CITY CERTIFIED MANAGERS AS REQUIRED.

Inadequate allergen knowledge can cause life-threatening allergic reactions.

Food allergen training required for certified managers.

Certified managers must complete allergen training; Staff must understand major allergens; Prevent cross-contact; Respond to customer inquiries.