YUMMY BUFFET Fails Health Inspection - Chicago Restaurant

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: OBSERVED NO EMPLOYEES HEALTH POLICY.MUST PROVIDE AND MAINTAIN.(PRIORITY FOUNDATION-7-38.010-NO CITATION ISSUED)

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: OBSERVED NO CLEAN-UP OF VOMITING AND DIARRHEA PROCEDURE AND CLEAN-UP KIT ON PREMISES DURING INSPECTION. INSTRUCTED TO HAVE SAID PROCEDURE ALONG WITH REQUIRED EQUIPMENT FOR CLEAN-UP. PRIORITY FOUNDATION VIOLATION. NO CITATION ISSUED. 7-38-005

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

PROPER DATE MARKING AND DISPOSITION - Comments: OBSERVED READY TO EAT, TIME FOR TEMPERATURE SAFETY FOR CONTROL FOODS NOT PROPERLY DATED IN ALL COOLERS. INSTRUCTED TO PROVIDE PROPER DATE MARKING WITH DISPOSITION DATE FOR RTE FOODS PREPARED ON SITE AND HELD OVER 24 HOURS IN COLD HOLDING UNIT. PRIORITY FOUNDATION VIOLATION. NO CITATION ISSUED. 7-38-005

Inadequate reheating fails to kill bacteria that grew during storage.

Foods must be reheated to 165°F within 2 hours.

Reheat to 165°F within 2 hours; Use proper equipment (not hot holding units); Discard if not reaching temperature in time.

CONSUMER ADVISORY PROVIDED FOR RAW/UNDERCOOKED FOOD - Comments: OBSERVED NO CONSUMER ADVISORY DISCLOSURE OR REMINDER OF RAW AND UNDER COOKED FOODS.MUST PROVIDE AND MAINTAIN.(PRIORITY FOUNDATION-NO CITATION ISSUED) STATEMENT THAT EATING RAW OR UNDERCOOKED FOODS CAN INCREASE YOUR RISK OF FOODBORNE ILLNESS. PRIORITY FOUNDATION 7-38-005. NO CITATION ISSUED.

Dirty surfaces attract pests and can contaminate food indirectly.

Non-food contact surfaces must be kept clean.

Clean as often as necessary; Remove grease and debris; Maintain equipment exteriors; Keep walls, ceilings, floors clean.

COMPLIANCE WITH VARIANCE/SPECIALIZED PROCESS/HACCP - Comments: FOUND SUSHI RICE ON SITE WITHOUT CURRENT LAB ANALYSIS. LAB ANALYSIS RESULT PROVIDED FROM "SILLIKER"INC ILLINOIS LABORATORIES # CHG-35599568-0 WITH DATE OF 9/26/2012. ANALYSIS AND RESULTS MUST BE COMPLETED WITHIN THE PAST FIVE YEARS AND PERSON IN CHARGE MUST MAINTAIN RECORDS VERIFYING THE PH RESULTS FROM A CERTIFIED LAB. PRIORITY FOUNDATION 7-38-005. NO CITATION ISSUED

Specialized processes without proper controls can create deadly toxins like botulism.

Special processes require approved HACCP plans or variances.

Written HACCP plan for: Vacuum packaging; Sous vide; Smoking for preservation; Curing; Using additives. Plan must be approved by CDPH.

CONTAMINATION PREVENTED DURING FOOD PREPARATION, STORAGE & DISPLAY - Comments: FOOD CONTAINERS STORED ON FLOOR IN WALK-IN COOLER AND FREEZERS. MUST PROVIDE PROPER, RAISED SHELVING TO STORE FOOD CONTAINERS 6" OFF FLOOR.

Contamination during preparation is a leading cause of foodborne illness.

Prevent contamination during all food handling.

Minimize bare hand contact; Prevent cross-contamination; Use clean equipment; Proper employee hygiene.

WIPING CLOTHS: PROPERLY USED & STORED - Comments: NOTED DIRTY WIPING CLOTHS ON PREP TABLES AT FRONT AND REAR PREP AREAS. NOT PROPERLY STORED. INSTRUCTED TO PROPERLY STORE ALL WASHCLOTHS IN A SANITIZING SOLUTION ESPECIALLY WHEN NOT IN USE

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED USE OF LARGE WOOD DISH FOR SUSHI RICE PREPARATION. MUST USE DISHES THAT ARE MADE FROM SMOOTH AND EASY CLEANABLE APPROVED MATERIALS

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: OBSERVED THAT CONCENTRATION OF SANITIZING SOLUTION IN LOW TEMPERATURE DISH MACHINE WITH CHLORINE SANITATION IS BELOW DETECTION. MUST REPAIR AND MAINTAIN RECOMMENDED CONCENTRATION OF CHLORINE SANITIZER. PRIORITY FOUNDATION VIOLATION 7-38-025 CITATION ISSUED

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: MUST CLEAN AND MAINTAIN CLEAN FLOORS IN WALK IN COOLER AND FREEZER FROM FOOD DEBRIS AND ICE.

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: BACKFLOW PREVENTION DEVICES NOT LOCATED AT ICE MACHINE AND SODA MACHINE. MUST INSTALL BACKFLOW PREVENTION DEVICES OR AIR GAP BETWEEN THE WATER SUPPLY INLET AND THE UNIT SO IT MAY BE LOCATED TO BE SERVICED AND MAINTAINED.

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: MUST INSTALL BACK FLOW PREVENTION ON HOSE INSTALLED FOR RINSING DISHES AND CONNECTED TO WATER SUPPLY LINE IN DISH WASHING AREA

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: MUST CLEAN AND MAINTAIN CLEAN REAR EXIT STORM DOOR FROM DUST AND DEBRIS

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: MUST REPAIR, REPLACE AND MAINTAIN ALL NON WORKING LIGHTS IN REAR DISH WASHING-PREP AREA

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: MUST REPAIR, REPLACE AND MAINTAIN ALL NON WORKING LIGHTS IN REAR DISH WASHING-PREP AREA

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.