TORTILLERIA ATOTONILCO, INC Fails Health Inspection - Chicago Wholesale

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: OBSERVED NO EMPLOYEE HEALTH POLICY ON SITE. INSTRUCTED TO PROVIDE AN EMPLOYEE HEALTH POLICY THAT INCLUDES A SIGNED ACKNOWLEDGEMENT FROM EACH EMPLOYEE. PRIORITY FOUNDATION. 7.38.010. NO CITATION ISSUED.

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: OBSERVED NO VOMIT AND DIARRHEA PROCEDURE OR CLEANING MATERIALS TO CLEAN UP SAID INCIDENT ON SITE. FACILITY MUST PROVIDE PROCEDURES AND CLEANING MATERIALS (GLOVES, MASK, DISPOSABLE MOP, DISINFECTANT RATED FOR NOROVIRUS) FOR EMPLOYEES TO FOLLOW AND USE WHEN RESPONDING TO VOMITING OR DIARRHEAL EVENTS. INSTRUCTED MANAGER TO PROVIDE. PRIORITY FOUNDATION VIOLATION. 7-38-005. NO CITATION ISSUED.

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

NO BARE HAND CONTACT WITH RTE FOOD OR A PRE-APPROVED ALTERNATIVE PROCEDURE PROPERLY ALLOWED - Comments: FOUND FOOD HANDLER PACKAGE READY TO EAT TORTILLAS WITH BARE HANDS. FOOD EMPLOYEES MAY NOT CONTACT EXPOSED, READY-TO-EAT FOOD WITH THEIR BARE HANDS. MUST USE SUITABLE UTENSILS SUCH AS DELI TISSUE, SPATULAS, TONGS, SINGLE-USE GLOVES, OR DISPENSING EQUIPMENT. PRIORITY VIOLATION. 7-38-010. CITATION ISSUED.

Contaminated water spreads waterborne diseases. Insufficient hot water prevents proper sanitization.

Potable water supply must be adequate, protected, and properly heated.

Water from approved public system; Sufficient pressure for all operations; Hot water minimum 120°F at fixtures, 180°F for high-temp dishwashers; Backflow prevention installed; No cross-connections.

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: FOUND HANDWASHING SINK WATER TEMPERATURE LOCATED IN WOMEN'S WASHROOM AT 43 F. ALSO NOTED HANDWASHING SINK LOCATED NEXT TO 3 COMPARTMENT SINK AT 46 F. MUST PROVIDE HOT WATER TEMPERATURE OF 100F AT ALL TIMES. MUST REPAIR AND MAINTAIN. PRIORITY VIOLATION. 7-38-030(C). CITATION ISSUED.

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: OBSERVED NO CHEMICAL TEST STRIPS ON SITE. INSTRUCTED PIC TO PROVIDE AND MAINTAIN AT ALL TIMES CHEMICAL TEST STRIPS TO TEST THE SANITIZING AGENT FOR THE THREE COMP SINK. PRIORITY FOUNDATION VIOLATION. 7-38-005. CITATION ISSUED.

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

TOILET FACILITIES: PROPERLY CONSTRUCTED, SUPPLIED, & CLEANED - Comments: FOUND NO COVERED GARBAGE RECEPTACLE LOCATED IN WOMENS WASHROOM. MUST PROVIDE.

Inadequate facilities lead to poor hygiene and contamination.

Toilet rooms must be properly equipped and maintained.

Self-closing doors; Toilet paper; Covered waste receptacles; Handwashing supplies; Cleaned regularly; Proper ventilation.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: FOUND CEILING LOCATED IN REAR COOK AREA PEELING OVER LARGE OPEN TANK WHERE FOOD IS PREPARED. MUST REPAIR AND MAINTAIN TO PREVENT PHYSICAL CONTAMINATION.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: FOUND UNSEALED CEMENT FLOORS THROUGHOUT FACILITY. MUST PROVIDE FLOORS CEILINGS AND WALLS THAT ARE SMOOTH AND EASILY CLEANABLE.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: FOUND STORAGE UPSTAIRS NEXT TO WASHROOMS CLUTTERED UNABLE TO SEE WALLS. MUST CLEAN ORGANIZE AND MAINTAIN TO PREVENT PEST HARBORAGE.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ALL FOOD EMPLOYEES HAVE FOOD HANDLER TRAINING - Comments: FOUND NO FOOD HANDLER TRAINING ON SITE. INSTRUCTED MANAGER TO PROVIDE PROOF OF FOOD HANDLER TRAINING.

Smoking contaminates hands and food with nicotine and tar residues.

Smoking prohibited in food establishments.

No smoking in any part of establishment; Designated areas away from food; Proper signage posted.

ALL FOOD EMPLOYEES HAVE FOOD HANDLER TRAINING - Comments: FOUND NO FOOD HANDLER TRAINING ON SITE. INSTRUCTED MANAGER TO PROVIDE PROOF OF FOOD HANDLER TRAINING.

Smoking contaminates hands and food with nicotine and tar residues.

Smoking prohibited in food establishments.

No smoking in any part of establishment; Designated areas away from food; Proper signage posted.