TORO ASIAN BUFFET, INC. Fails Health Inspection - Chicago Restaurant

FOOD-CONTACT SURFACES: CLEANED & SANITIZED - Comments: OBSERVED THE LOW TEMPERATURE DISH MACHINE NOT PROPERLY SANITIZING AT 0PPM OF CHLORINE DURING THE INSPECTION. INSTRUCTED MANAGER SAID EQUIPMENT MUST PROPERLY SANITIZE AT 50PPM-100PPM OF CHLORINE ALL TIMES. UNIT TAGGED AND HELD FOR INSPECTION BY THE DEPARTMENT OF HEALTH AND MAY NOT BE USED. PRIORITY VIOLATION. CITATION ISSUED 7-38-025.

Dirty equipment harbors and spreads pathogens, causing cross-contamination and illness.

All food contact surfaces must be properly cleaned and sanitized.

Wash, rinse, sanitize after each use; Clean between different raw foods; Every 4 hours for continuous use; When contaminated; Proper procedures and chemicals.

PROPER COLD HOLDING TEMPERATURES - Comments: OBSERVED TCS FOODS HELD AT IMPROPER INTERNAL TEMPERATURES IN THE REAR PREP AREA, SUCH AS 50LBS OF CHICKEN AT 75.2F, 15LBS SHRIMP AT 62.8F AND 10LBS OF FISH AT 64.4F. MANAGER DISCARDED AND DENATURED A TOTAL 75LBS AT $250. ALL COLD TCS FOOD MUST MAINTAIN 41F OR BELOW . PRIORITY VIOLATION. CITATION ISSUED 7-38-005.

Temperatures below 135°F allow bacteria to multiply, especially spore-formers that survive cooking.

Hot foods must be held at 135°F or above.

Maintain 135°F or above; Check temperatures regularly; Proper hot holding equipment; Cannot reheat in hot holding units.

APPROVED THAWING METHODS USED - Comments: OBSERVED FROZEN MEAT THAWING IN A PLASTIC CONTAINER IN THE FOOD PREP AREA. MANAGEMENT INSTRUCTED TO THAW TCS FOODS UNDER COLD RUNNING WATER, IN THE REFRIGERATOR OR IN THE MICROWAVE AS PART OF A CONTINUOUS COOKING PROCESS.

Damaged surfaces cannot be properly cleaned and may harbor pests.

Walls and ceilings must be smooth, cleanable, and in good repair.

Smooth, washable surfaces in food areas; Light colored; No holes or cracks; Clean and maintained.

FOOD PROPERLY LABELED; ORIGINAL CONTAINER - Comments: OBSERVED ITEMS OUT OF THE ORIGINAL CONTAINERS WITHOUT LABELS CONTAINING THE PRODUCT NAME. INSTRUCTED TO LABEL ALL FOODS AND SPICES WITH COMMON NAME THAT ARE OUT OF THE ORIGINAL CONTAINERS.

Missing allergen labeling can cause severe allergic reactions.

All food properly labeled with required information.

Common name; Ingredients; Allergen declarations; Date marking; Manufacturer info; Net quantity.

CONTAMINATION PREVENTED DURING FOOD PREPARATION, STORAGE & DISPLAY - Comments: OBSERVED FOOD ITEMS STORED ON FLOOR IN WALK-IN COOLER AND FREEZER AND PREP AREAS. INSTRUCTED MANAGER TO ELEVATE ALL FOOD SIX INCHES OFF FLOOR.

Contamination during preparation is a leading cause of foodborne illness.

Prevent contamination during all food handling.

Minimize bare hand contact; Prevent cross-contamination; Use clean equipment; Proper employee hygiene.

WIPING CLOTHS: PROPERLY USED & STORED - Comments: OBSERVED SOILED WIPING CLOTHS STORED ON PREP TABLES. INSTRUCTED MANAGER TO STORE IN SANITIZING SOLUTION BETWEEN USES.

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED THE INSIDE OF THE DEEP FRYER OIL FILTERING UNIT WITH A BUILD UP OF GREASE AND FOOD DEBRIS. INSTRUCTED TO CLEAN AND MAINTAIN ALL

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: OBSERVED NO SANITIZER TESTING DEVICES ON SITE AT TIME OF INSPECTION. INSTRUCTED TO PROVIDE. PRIORITY FOUNDATION VIOLATION 7-38-005. CITATION ISSUED.

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: OBSERVED ACCUMULATED GREASE AND FOOD DEBRIS ON INTERIOR AND EXTERIOR SURFACES OF COOKING EQUIPMENT, PREP TABLES, COOLERS, FREEZERS, SHELVING UNITS. INSTRUCTED MANAGER TO CLEAN AND MAINTAIN.

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: OBBSERVED MINOR LEAK AT THE SINK BY THE LOW DISHWASHING MACHINE. INSTRUCTED TO FIX AND MAINTAIN

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: FOUND AN ACCUMULATION DIRT AND OLD FOOD DEBRIS ON THE FLOOR AND INSIDE THE DRAIN UNDERNEATH THE DUMP SINK LOCATED NEXT TO THE COFFEE BEAN GRINDER. MUST DETAIL CLEAN AND MAINTAIN

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: FOUND AN ACCUMULATION DIRT AND OLD FOOD DEBRIS ON THE FLOOR AND INSIDE THE DRAIN UNDERNEATH THE DUMP SINK LOCATED NEXT TO THE COFFEE BEAN GRINDER. MUST DETAIL CLEAN AND MAINTAIN

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.