SUPERMERCADO ANTONIO'S CORP. Fails Health Inspection - Chicago Grocery store

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: OBSERVED EXPOSED HAND WASHING SINK IN REAR PREP AREA CLOGGED AND WATER NOT DRAINING SO HANDS CAN NOT BE WASHED THERE. INSTRUCTED TO REPAIR AND MAINTAIN ALL EXPOSED HAND WASHING SINKS. PRIORITY FOUNDATION VIOLATION 7-38-030(C). CITATION ISSUED.

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

PROPER COLD HOLDING TEMPERATURES - Comments: OBSERVED TCS FOOD AT IMPROPER TEMPERATURE REQUIREMENT STORED SITTING OUTSIDE OF WALKING IN COOLER. FOUND TEMPERATURE OF BBQ CHICKEN AT 78.8F INSTRUCTED ALL TCS FOODS MUST MAINTAIN COLD HOLDING TEMPERATURE OF BELOW 41.0F AND HOT HOLDING TEMPERATURE OF ABOVE 135.0F. OPERATOR VOLUNTARILY DISCARDED AND DENATURED FOODS DURING INSPECTION. PRIORITY VIOLATIONI 7-38-005. CITATION ISSUED.

Temperatures below 135°F allow bacteria to multiply, especially spore-formers that survive cooking.

Hot foods must be held at 135°F or above.

Maintain 135°F or above; Check temperatures regularly; Proper hot holding equipment; Cannot reheat in hot holding units.

PROPER DATE MARKING AND DISPOSITION - Comments: OBSERVED PREPARED TCS FOOD ITEMS COOKED CHICKEN, COOKED PORK, BBQ CHICKEN, ETC.) IN WALK IN COOLER WITHOUT LABELS. INSTRUCTED TO PROVIDE DISCARD DATE LABELS (NOT TO EXCEED 7 DAYS) ON ALL FOODS PREPARED ON SITE AND HELD FOR MORE THAN 24 HOURS AND MAINTAIN. PRIORITY FOUNDATION VIOLATION 7-38-005. CITATION ISSUED.

Inadequate reheating fails to kill bacteria that grew during storage.

Foods must be reheated to 165°F within 2 hours.

Reheat to 165°F within 2 hours; Use proper equipment (not hot holding units); Discard if not reaching temperature in time.

CONTAMINATION PREVENTED DURING FOOD PREPARATION, STORAGE & DISPLAY - Comments: OBSERVED FOOD ITEMS STORED ON FLOOR IN WALK-IN COOLER AND FREEZER. INSTRUCTED MANAGER TO ELEVATE ALL FOOD SIX INCHES OFF FLOOR.

Contamination during preparation is a leading cause of foodborne illness.

Prevent contamination during all food handling.

Minimize bare hand contact; Prevent cross-contamination; Use clean equipment; Proper employee hygiene.

WIPING CLOTHS: PROPERLY USED & STORED - Comments: OBSERVED SOILED WIPING CLOTHS STORED ON PREP TABLES. INSTRUCTED MANAGER TO STORE IN SANITIZING SOLUTION BETWEEN USES.

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: NOTED SOME USE OF MILK CRATES FOR ELEVATION AT THE WALK-IN COOLER AND DRY STORAGE AREA. INSTRUCTED NOT TO USE MILK CRATES FOR ELEVATION TO PREVENT HIDING PLACES FOR PEST. MUST PROVIDE APPROPRIATE SHELVING FOR STORAGE. ALL FOOD ITEMS MUST ALSO BE STORED 6" AWAY FROM THE WALL

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED CUTTING BOARD ON BUTCHER LINE COVERED WITH DEEP GROOVES AND DARK STAINS. INSTRUCTED TO REPAIR OR REPLACE AND MAINTAIN SMOOTH, CLEANABLE SURFACES.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: FOUND THE THREE COMPARTMENT SINK NOT MAINTAINED; SINK IS SLOW DRAINING. WHEN WATER FROM ONE COMPARTMENT IS DRAINED; WATER BACKS UP INTO ADJACENT COMPARTMENTS. INSTRUCTED MANAGEMENT TO GET DRAINAGE SYSTEM SERVICED. PRIORITY FOUNDATION 7-38-025. CITATION ISSUED.

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

TOILET FACILITIES: PROPERLY CONSTRUCTED, SUPPLIED, & CLEANED - Comments: OBSERVED GARBAGE CAN INSIDE UNISEX TOILET ROOM WITHOUT COVERING INSIDE OF TOILET ROOM. MUST PROVIDE LID AND MAINTAIN.

Inadequate facilities lead to poor hygiene and contamination.

Toilet rooms must be properly equipped and maintained.

Self-closing doors; Toilet paper; Covered waste receptacles; Handwashing supplies; Cleaned regularly; Proper ventilation.

GARBAGE & REFUSE PROPERLY DISPOSED; FACILITIES MAINTAINED - Comments: OBSERVED DEBRIS AROUND DUMPSTER . INSTRUCTED TO CLEAN AND MAINTAIN.

Poor waste management attracts pests and creates contamination sources.

Refuse must be properly contained and removed.

Leak-proof, pest-proof containers; Tight-fitting lids; Clean storage areas; Frequent removal; Containers cleaned.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED RUSTY AND UNEVEN FLOOR INSIDE OF WALK IN FREEZER.MUST MAKE SMOOTH AND EASILY CLEANABLE.MUST REPAIR OR REPLACE DAMAGED WALL TILE UNDER HAND SINK IN REAR PREP/DISH WASHING AREA,DAMAGED AND MISSING FLOOR TILES ON SALES FLOOR.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED EXCESSIVE STORED ITEMS (FOOD ITEMS INSIDE STACKED CRATES, COOKING EQUIPMENT, STORE MATERIALS AND OTHER STORED HOUSEHOLD ITEMS THROUGHOUT. MUST REMOVE ALL UNNECCSARY ITEMS IN ORDER TO PREVENT PEST HARBORAGE AND MAINTAIN PREMISE.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ALL FOOD EMPLOYEES HAVE FOOD HANDLER TRAINING - Comments: OBSERVED NO FOOD HANDLER CERTIFICATES ON SITE AT TIME OF INSPECTION. INSTRUCTED ALL EMPLOYEES MUST COMPLETE FOOD HANDLER TRAINING AND MAINTAIN RECORDS THEREOF ON SITE AT ALL TIMES.

Smoking contaminates hands and food with nicotine and tar residues.

Smoking prohibited in food establishments.

No smoking in any part of establishment; Designated areas away from food; Proper signage posted.

ALL FOOD EMPLOYEES HAVE FOOD HANDLER TRAINING - Comments: OBSERVED NO FOOD HANDLER CERTIFICATES ON SITE AT TIME OF INSPECTION. INSTRUCTED ALL EMPLOYEES MUST COMPLETE FOOD HANDLER TRAINING AND MAINTAIN RECORDS THEREOF ON SITE AT ALL TIMES.

Smoking contaminates hands and food with nicotine and tar residues.

Smoking prohibited in food establishments.

No smoking in any part of establishment; Designated areas away from food; Proper signage posted.