SPINNING J Gets Conditional Pass on Health Inspection - Chicago Bakery

FOOD-CONTACT SURFACES: CLEANED & SANITIZED - Comments: OBSERVED LOW TEMPERATURE DISH WASHING MACHINE IN USE NOT PROPERLY SANITIZING. SANITIZING STRENGTH OF SANITIZER (CHLORINE) AT THE TIME OF INSPECTION WAS 0 PPM. EQUIPMENT MUST PROPERLY SANITIZE AT A MINIMUM OF 50 PPM. INSTRUCTED TO WASH, RINSE AND SANITIZE IN THE THREE COMPARTMENT SINK IN THE DISH AREA AND NOT TO USE UNIT UNTIL REINSPECTED BY CHICAGO DEPARTMENT OF HEALTH (CDPH). TAGGED UNIT. PRIORITY VIOLATION #7-38-025. CITATION ISSUED.

Dirty equipment harbors and spreads pathogens, causing cross-contamination and illness.

All food contact surfaces must be properly cleaned and sanitized.

Wash, rinse, sanitize after each use; Clean between different raw foods; Every 4 hours for continuous use; When contaminated; Proper procedures and chemicals.

WIPING CLOTHS: PROPERLY USED & STORED - Comments: OBSERVED WET WIPING CLOTHS ON SEVERAL PREP SURFACE AREAS. INSTRUCTED TO PROPERLY STORE WIPING CLOTHS IN A SANITIZING SOLUTION BETWEEN USES TO PREVENT CONTAMINATION OF EQUIPMENT & FOOD. MUST MAINTAIN

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED MILK CRATES BEING USED AS SHELVING THROUGHOUT THE BASEMENT STORAGE AREA. MUST REMOVE AND PROVIDE SHELVING THAT IS 6" OFF THE FLOOR AND PROVIDES FLOOR ACCESSIBILITY TO ENSURE ADEQUATE FACILITY CLEANING.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: OBSERVED FOOD DEBRIS ON THE FLOORS IN THE WALK-IN COOLER. INSTRUCTED TO CLEAN AND MAINTAIN.

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: OBSERVED FOOD DEBRIS ON THE FLOORS IN THE WALK-IN COOLER. INSTRUCTED TO CLEAN AND MAINTAIN.

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.