SI-PIE Gets Conditional Pass on Health Inspection - Chicago Restaurant

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: NOTED NO EMPLOYEE HEALTH POLICY ON SITE AT THE TIME OF INSPECTION FOLLOWING THE NEW CODE AND GUIDELINES. INSTRUCTED TO HAVE VERIFICATION OF POLICY FOR EACH EMPLOYEE ONE ON SITE AT ALL TIMES. PRIORITY FOUNDATION #7-38-010. NO CITATION ISSUED TODAY

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: MANAGEMENT UNABLE TO PROVIDE A PROCEDURE FOR CLEANING UP VOMITING AND DIARRHEA.INSTRUCTED TO HAVE ONE INCLUDING THE CHEMICALS AND SUPPLIES NEEDED. PRIORITY FOUNDATION #7-38-005. NO CITATION ISSUED

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

PROPER COLD HOLDING TEMPERATURES - Comments: NOTED INTERNAL TEMPERATURE OF THE FOLLOWING TCS FOOD ITEMS INSIDE SERVICE COOLERS TO BE IMPROPER:-COLESLAW 53.6F, PASTA SALAD 48.9F, POTATO SALAD 54.0F, GYRO MEAT 46.4F,CHEESE 45,7F. MANAGER IMMEDIATELY AND VOLUNTARILY DISPOSED OF 15 LBS OF PRODUCTS WORTH $100.00 THROUGH DENATURING PROCESS. PRIORITY VIOLATION #7-38-005

Temperatures below 135°F allow bacteria to multiply, especially spore-formers that survive cooking.

Hot foods must be held at 135°F or above.

Maintain 135°F or above; Check temperatures regularly; Proper hot holding equipment; Cannot reheat in hot holding units.

PROPER DATE MARKING AND DISPOSITION - Comments: NOTED TEMPERATURE CONTROLLED FOR SAFETY FOOD ITEMS INSIDE WALK IN COOLER AND REFRIGERATION UNITS NOT PROPERLY LABELED. INSTRUCTED TO PROPERLY LABEL ALL READY TO EAT FOOD ITEMS WITH PRODUCT NAME AND USED BY DATE. PRIORITY FOUNDATION #7-38-005(A). NO CITATION ISSUED TODAY.

Inadequate reheating fails to kill bacteria that grew during storage.

Foods must be reheated to 165°F within 2 hours.

Reheat to 165°F within 2 hours; Use proper equipment (not hot holding units); Discard if not reaching temperature in time.

PROPER COOLING METHODS USED; ADEQUATE EQUIPMENT FOR TEMPERATURE CONTROL - Comments: 4-301.11 EQUIPMENT NOT MAINTAINING PROPER TEMPERATURE. NOTED TEMPERATURE OF SERVICE COOLER AT THE PREP AREA TO BE IMPROPER AT 55.6F. INSTRUCTED NOT TO USE EQUIPMENT UNTIL MAINTAINING PROPER TEMPERATURE OF 41F AND BELOW. PRIORITY VIOLATION 7-38-005

Dirty equipment harbors bacteria and attracts pests.

All equipment and utensils must be clean and properly maintained.

Equipment clean to sight and touch; Free of food debris and grease; Maintained in good repair; Stored properly when clean.

THERMOMETERS PROVIDED & ACCURATE - Comments: NOTED NO THERMOMETERS INSIDE REFRIGERATION UNIT CONSPICUOUSLY POSTED TO MONITOR THE AMBIENT TEMPERATURE OF EQUIPMENT. INSTRUCTED TO EQUIP ALL REFRIGERATION UNITS WITH ACCURATE AND WORKING THERMOMETERS.

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

FOOD PROPERLY LABELED; ORIGINAL CONTAINER - Comments: PREPACKAGED FOODS ON DISPLAY NOT PROPERLY LABELED. MUST LABEL PACKAGES WITH FOOD NAME, INGREDIENTS, NET CONTENTS, SOURCE AND LIST OF ALLERGENS. PRIORITY FOUNDATION 7-38-005.NO CITATION ISSUED.

Missing allergen labeling can cause severe allergic reactions.

All food properly labeled with required information.

Common name; Ingredients; Allergen declarations; Date marking; Manufacturer info; Net quantity.

FOOD PROPERLY LABELED; ORIGINAL CONTAINER - Comments: NOTED ASSORTED FOOD ITEMS INSIDE REFRIGERATION UNITS NOT PROPERLY LABELED. INSTRUCTED TO PROPERLY LABEL ALL FOOD ITEMS WITH PRODUCT NAME INCLUDING BULK FOOD CONTAINERS.

Missing allergen labeling can cause severe allergic reactions.

All food properly labeled with required information.

Common name; Ingredients; Allergen declarations; Date marking; Manufacturer info; Net quantity.

CONTAMINATION PREVENTED DURING FOOD PREPARATION, STORAGE & DISPLAY - Comments: NOTED AN UNLOCKED REFRIGERATION UNIT WITH FOOD ITEMS BY THE EMPLOYEE/CUSTOMER WASH ROOM AREA . MUST RELOCATE EQUIPMENT, PROVIDE A LOCK FOR THE EQUIPMENT OR REMOVE FOOD ITEMS AND STORE ONLY BEVERAGES INSIDE THE REFRIGERATION UNIT.

Contamination during preparation is a leading cause of foodborne illness.

Prevent contamination during all food handling.

Minimize bare hand contact; Prevent cross-contamination; Use clean equipment; Proper employee hygiene.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: 4-202.16 NOTED SOME USE OF MILK CRATES FOR ELEVATION AT THE KITCHEN AREA, DISHWASHING AREA AND DRY STORAGE AREA. INSTRUCTED NOT TO USE MILK CRATES FOR ELEVATION TO PREVENT HIDING PLACES FOR PEST. MUST PROVIDE APPROPRIATE SHELVING FOR STORAGE. ALL FOOD ITEMS MUST ALSO BE STORED 6" AWAY FROM THE WALL

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: NOTED TORN RUBBER GASKET INSIDE THE PREP SERVICE COOLER AT THE KITCHEN PREP. INSTRUCTED TO DETAIL REPAIR AND MAINTAIN AND/OR REPLACE

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: NOTED A SLIMY AND GREY SUBSTANCE INSIDE THE SODA DISPENSER DRAIN AND 3 COMPARTMENT SINK DRAINS AT THE REAR DISH WASHING AREA. INSTRUCTED TO CLEAN, SANITIZE AND MAINTAIN ALL DRAINS.

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

SEWAGE & WASTE WATER PROPERLY DISPOSED - Comments: 3 COMPARTMENT SINK NOT MAINTAINED. NOTED WASTE WATER FROM INTO 2 OF 3 COMPARTMENT SINK WITH GREASE, DIRT AND OLD FOOD PARTICLES WHEN WATER IS RELEASED FROM ONE OF THE COMPARTMENT SINK. MANAGER IMMEDIATELY CALLED PLUMBER FOR MAINTENANCE. PRIORITY VIOLATION #7-38-030(C)

Improper disposal contaminates environment and attracts pests.

All waste water must be properly disposed.

Discharge to approved sewer; No dumping outside; Grease trap maintained; No floor draining to exterior.

TOILET FACILITIES: PROPERLY CONSTRUCTED, SUPPLIED, & CLEANED - Comments: NOTED GARBAGE CANS INSIDE UNISEX BATHROOM WITH NO LID. INSTRUCTED TO PROVIDE A LID FOR THE RECEPTACLE.

Inadequate facilities lead to poor hygiene and contamination.

Toilet rooms must be properly equipped and maintained.

Self-closing doors; Toilet paper; Covered waste receptacles; Handwashing supplies; Cleaned regularly; Proper ventilation.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: NOTED HEAVY CLUTTER THROUGHOUT ESTABLISHMENT ON SHELVES, FLOORS INSIDE UNUSED EQUIPMENT AND IN STORAGE AREAS. INSTRUCTED TO DETAIL CLEAN, ORGANIZE AND REMOVE ALL UNNECESSARY OR UNUSED ARTICLES AND EQUIPMENT TO PREVENT HIDING PLACES FOR PEST. MUST UPGRADE HOUSING KEEPING.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: NOTED DIRTY AND DUSTY CEILING FANS AT THE REAR AND FRONT PREP AREAS. INSTRUCTED TO CLEAN AND MAINTAIN.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: NOTED THE FOLLOWING:- -FLOORS THROUGHOUT PREMISE ESPECIALLY ALONG WALL BASE AND UNDERNEATH EQUIPMENT WITH DIRT, GREASE AND FOOD DEBRIS. -WALLS WITH FOOD DIRT AND FOOD SPILLS. INSTRUCTED TO DETAIL CLEAN AND SANITIZE ESPECIALLY AREAS WITH PEST ACTIVITY, CLEAN AND MAINTAIN WALLS WITH CRACKS AND SPILLS. MUST UPGRADE HOUSEKEEPING.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: INSTRUCTED TO DETAIL CLEAN AND MAINTAIN ALL COOKING EQUIPMENT, INGREDIENT CONTAINERS, RACKS AND SHELVING WITH CRUMBS, DUST, GREASE, AND DIRT BUILD-UP THROUGHOUT.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: NOTED ROUGH AND UNFINISHED BRICK WALLS BEHIND THE SODA DISPENSING MACHINE. INSTRUCTED TO REFINISH WALLS TO BE SMOOTH AND EASILY CLEANABLE.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: NOTED HEAVY DIRT AND GREASE ACCUMULATION INSIDE, ON PIPES/CONDUITS AND ON EDGES OF THE EXHAUST HOOD AND FILTERS ABOVE COOKING EQUIPMENT. INSTRUCTED TO DETAIL CLEAN AND MAINTAIN HOOD, FILTERS AND PIPES/CONDUITS.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: NOTED HEAVY DIRT AND GREASE ACCUMULATION INSIDE, ON PIPES/CONDUITS AND ON EDGES OF THE EXHAUST HOOD AND FILTERS ABOVE COOKING EQUIPMENT. INSTRUCTED TO DETAIL CLEAN AND MAINTAIN HOOD, FILTERS AND PIPES/CONDUITS.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.