SANDY'S BAKERY & DELI INC Gets Conditional Pass on Health Inspection - Chicago Bakery

SANITIZING RINSE FOR EQUIPMENT AND UTENSILS: CLEAN, PROPER TEMPERATURE, CONCENTRATION, EXPOSURE TIME - Comments: Observed employee washing large tubs for food storage in the 1 compartment sink without fully submerging utensil. Instructed facility to wash utensil in the three compartment sink with each compartment filled with water and appropriate contents-1 for wash with soap and water, 1 for rinse with only water, and 1 for sanitizing with water and appropriate sanitizer solution. Instructed to comply and maintain. Facility washed in three compartment sink at time of inspection. Critical citation issued 7-38-030.

Improper sanitization fails to kill pathogens, allowing contaminated equipment to spread illness throughout facility.

Sanitizing solutions and rinse water must meet specific requirements for effectiveness.

Chemical sanitizers: Chlorine 50-100 ppm, Quaternary ammonium 200-400 ppm, Iodine 12.5-25 ppm; Hot water: 171°F for 30 seconds or 180°F at dish surface; Test strips required; Proper contact time.

FOOD PROTECTED DURING STORAGE, PREPARATION, DISPLAY, SERVICE AND TRANSPORTATION - Comments: Observed food for customer self service not protected- tub full of pork cracklins uncovered where customers can scoop for self service. Instructed to protect and maintain. Facility covered during inspection. Observed food not protected- facility is bottling and capping yogurt made in store without CDPH approval. Facility is also curing meats on site without CDPH approval. Tagged all yogurt and cured items held for inspection by CDPH, do not remove or use without CDPH approval. Serious citation issued 7-38-005(a).

Dirty equipment harbors and spreads pathogens, causing cross-contamination and illness.

All food contact surfaces must be properly cleaned and sanitized.

Wash, rinse, sanitize after each use; Clean between different raw foods; Every 4 hours for continuous use; When contaminated; Proper procedures and chemicals.

FOOD IN ORIGINAL CONTAINER, PROPERLY LABELED: CUSTOMER ADVISORY POSTED AS NEEDED - Comments: Instructed facility to label bulk food containers and to maintain.

Improper methods result in slow cooling that allows bacterial growth.

Approved cooling methods must be used.

Use shallow pans, ice baths, rapid chill units, ice wands; Cut large items into smaller portions; Stir frequently; Leave uncovered during cooling.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: Observed food being stored in plastic grocery bags. Instructed to store in food grade materials only and to maintain.

Unapproved processes may lack critical safety controls.

Variance required before conducting specialized food processes.

Submit application to CDPH; Include HACCP plan; Await approval before starting; Maintain all required records.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: Observed dirt accumulation in the 2 door cooler in the front prep area. Instructed facility to clean and maintain.

Dirty equipment harbors bacteria and attracts pests.

All equipment and utensils must be clean and properly maintained.

Equipment clean to sight and touch; Free of food debris and grease; Maintained in good repair; Stored properly when clean.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: Observed a dirty, sticky, worn rug on the basement floor near the bathroom. Instructed facility to discard and maintain. Observed heavy dirt, charcoal, cardboard, and debris on the floor in the roasting room. Instructed facility to clean and maintain. Observed oil and debris on the floor along the wall under the baker's tables. Instructed facility to clean and maintain.

Damaged floors harbor bacteria and create safety hazards.

Floors must be smooth, cleanable, and maintained.

Smooth, non-porous in food areas; Properly sloped to drains; Coving at wall junctures; Kept clean; Good repair.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: Observed the exhaust hood filters to have dirt and grease accumulation in both the front and rear prep. Instructed to clean and maintain. Observed stained ceiling tiles in the rear prep area. Instructed to replace and maintain. Observed dirt accumulation on the walk in cooler fanguards. Instructed facility to clean and maintain.

Damaged surfaces cannot be properly cleaned and may harbor pests.

Walls and ceilings must be smooth, cleanable, and in good repair.

Smooth, washable surfaces in food areas; Light colored; No holes or cracks; Clean and maintained.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: Observed the utility sink near the 1 compartment sink to have duct tape on the faucet and a small leak. Instructed to repair, remove tape, and maintain.

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: Observed the utility sink near the 1 compartment sink to have duct tape on the faucet and a small leak. Instructed to repair, remove tape, and maintain.

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.