RACINE BAKERY INC Gets Conditional Pass on Health Inspection - Chicago Bakery

HANDS WASHED AND CLEANED, GOOD HYGIENIC PRACTICES; NO BARE HAND CONTACT WITH READY-TO-EAT FOODS. - Comments: POOR HYGIENIC PRACTICES: OBSERVED A FEMALE FOOD HANDLER WEARING GLOVES, GO OUTSIDE AND DISCARD GARBAGE THEN RETURN TO PREP AREA AND BEGAN HANDLING READY TO EAT FOODS (PASTRIES). SHE DID NOT WASH HER HANDS NOR DID SHE REMOVE THE GLOVES. INSTRUCTED TO WASH HANDS BEFORE/AFTER WEARING GLOVES, LEAVING/RETURNING TO PREP AREA, MULTI-TASKING, ETC. CRITICAL VIOLATION 7-38-010(A)

Hands are #1 vehicle for pathogen transfer. Bare hand contact with ready-to-eat foods causes majority of foodborne outbreaks.

Proper handwashing and no bare hand contact with ready-to-eat foods.

Wash hands for 20 seconds with soap and warm water; Use utensils, deli tissue, or gloves for ready-to-eat foods; Wash hands after restroom, handling raw foods, touching face/hair, and between tasks.

FOOD PROTECTED DURING STORAGE, PREPARATION, DISPLAY, SERVICE AND TRANSPORTATION - Comments: FOOD NOT PROTECTED DURING STORAGE: OBSERVED RAW CHICKEN STORED OVER READY TO EAT FOODS(COOKED CHICKEN), AND SHELLED EGGS OVER VEGETABLES. INSTRUCTED TO STORE RAW MEAT AND SHELLED EGGS UNDER READY TO EAT FOOD ITEMS AND VEGETABLES.

Dirty equipment harbors and spreads pathogens, causing cross-contamination and illness.

All food contact surfaces must be properly cleaned and sanitized.

Wash, rinse, sanitize after each use; Clean between different raw foods; Every 4 hours for continuous use; When contaminated; Proper procedures and chemicals.

FOOD IN ORIGINAL CONTAINER, PROPERLY LABELED: CUSTOMER ADVISORY POSTED AS NEEDED - Comments: UNLABELED BULK INGREDIENT CONTAINERS IN PREP AREA AND DRY STORAGE. INSTRUCTED TO LABEL ALL BULK FOOD CONTAINERS.

Improper methods result in slow cooling that allows bacterial growth.

Approved cooling methods must be used.

Use shallow pans, ice baths, rapid chill units, ice wands; Cut large items into smaller portions; Stir frequently; Leave uncovered during cooling.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: OBSERVED GASKETS OF 3 DOOR REACH IN COOLER IN GARAGE WITH TORN GASKETS. INSTRUCTED TO REPLACE GASKETS.

Unapproved processes may lack critical safety controls.

Variance required before conducting specialized food processes.

Submit application to CDPH; Include HACCP plan; Await approval before starting; Maintain all required records.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: OBSERVED RACKS OF ALL REFRIGERATION IN PREP AREAS AND GARAGE WITH RUST. INSTRUCTED TO REMOVE RUST FROM RACKS AND MAINTAIN.

Unapproved processes may lack critical safety controls.

Variance required before conducting specialized food processes.

Submit application to CDPH; Include HACCP plan; Await approval before starting; Maintain all required records.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: MUST PROVIDE EFFECTIVE SHIELD AT THE TOP OF BAKED GOODS IN THE FRONT CUSTOMER SERVICE AREA.

Unapproved processes may lack critical safety controls.

Variance required before conducting specialized food processes.

Submit application to CDPH; Include HACCP plan; Await approval before starting; Maintain all required records.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: DETAIL CLEAN AND MAINTAIN THE FOLLOWING:INTERIOR AND EXTERIOR OF COOKING EQUIPMENT, SHELVING, PREP TABLE AND STORAGE RACKS THROUGHOUT. MUST REMOVE ALL FOOD DEBRIS, GREASE, DIRT/DUST BUILD UP.

Dirty equipment harbors bacteria and attracts pests.

All equipment and utensils must be clean and properly maintained.

Equipment clean to sight and touch; Free of food debris and grease; Maintained in good repair; Stored properly when clean.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: MUST DETAIL CLEAN AND MAINTAIN: HEAVY BUILD UP OF FOOD DEBRIS UNDER/BEHIND ALL FOOD EQUIPMENT, IN STORAGE AREAS, FLOOR DRAINS AND CORNERS THROUGHOUT.

Damaged floors harbor bacteria and create safety hazards.

Floors must be smooth, cleanable, and maintained.

Smooth, non-porous in food areas; Properly sloped to drains; Coving at wall junctures; Kept clean; Good repair.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: MUST KEEP ALL FOOD ELEVATED (AT LEAST 6") IN THE WALK IN COOLERS AND WALK IN FREEZERS IN THE REAR PREP AREA.

Damaged floors harbor bacteria and create safety hazards.

Floors must be smooth, cleanable, and maintained.

Smooth, non-porous in food areas; Properly sloped to drains; Coving at wall junctures; Kept clean; Good repair.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: MUST REPLACE/REPAIR ALL MISSING/BROKEN FLOOR TILES THROUGHOUT PREP AREAS.

Damaged floors harbor bacteria and create safety hazards.

Floors must be smooth, cleanable, and maintained.

Smooth, non-porous in food areas; Properly sloped to drains; Coving at wall junctures; Kept clean; Good repair.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: MUST DETAIL CLEAN AND MAINTAIN: WALLS IN PREP AND STORAGE AREAS, HOOD VENTS IN PREP AREAS, FAN COVERS OF FRONT WALK IN COOLER IN REAR PREP AREA,

Damaged surfaces cannot be properly cleaned and may harbor pests.

Walls and ceilings must be smooth, cleanable, and in good repair.

Smooth, washable surfaces in food areas; Light colored; No holes or cracks; Clean and maintained.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: MUST REMOVE WATER STAINED CEILING TILES THROUGHOUT REAR AND FRONT PREP AREAS.

Damaged surfaces cannot be properly cleaned and may harbor pests.

Walls and ceilings must be smooth, cleanable, and in good repair.

Smooth, washable surfaces in food areas; Light colored; No holes or cracks; Clean and maintained.

LIGHTING: REQUIRED MINIMUM FOOT-CANDLES OF LIGHT PROVIDED, FIXTURES SHIELDED - Comments: PROVIDE LIGHT SHIELDS AND MAINTAIN IN DRY STORAGE AREA, GARAGE STORAGE AND IN THE DESSERT COOLER IN THE FRONT CUSTOMER SERVICE AREA.

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

LIGHTING: REQUIRED MINIMUM FOOT-CANDLES OF LIGHT PROVIDED, FIXTURES SHIELDED - Comments: REPLACE BLOWN LIGHT BULBS IN WALK IN COOLER #4 AND IN THE PREP AREAS.

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: FIX AND MAINTAIN THE FOLLOWING LEAKS: 3 COMPARTMENT SINK PLUMBING UNDERNEATH THE 2ND BASIN, KITCHEN HANDSINK PLUMBING UNDERNEATH AND CAKE PREP ROOM HANDSINK FAUCET BASE.

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: REAR EMPLOYEE RESTROOM WITH NO VENTILATION. INSTRUCTED TO PROVIDE PROPER VENTILATION.

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: MUST HAVE ALL COOKING EQUIPMENT UNDER THE HOOD IN THE KITCHEN PREP AREA.

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

PREMISES MAINTAINED FREE OF LITTER, UNNECESSARY ARTICLES, CLEANING EQUIPMENT PROPERLY STORED - Comments: OBSERVED EMPLOYEE PERSONAL ITEMS STORED OVER FOOD PREP AREAS. INSTRUCTED TO REMOVE EMPLOYEE PERSONAL ITEMS AND STORE SEPARATELY.

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.

PREMISES MAINTAINED FREE OF LITTER, UNNECESSARY ARTICLES, CLEANING EQUIPMENT PROPERLY STORED - Comments: OBSERVED EXCESS CLUTTER THROUGHOUT. ELIMINATE EXCESS CLUTTER AND BETTER ORGANIZE.

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.

PREMISES MAINTAINED FREE OF LITTER, UNNECESSARY ARTICLES, CLEANING EQUIPMENT PROPERLY STORED - Comments: OBSERVED DUMPSTER AREA WITH EXCESS LEAVES. INSTRUCTED TO REMOVE EXCESS LEAVES AND MAINTAIN DUMPSTER AREA.

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.

PREMISES MAINTAINED FREE OF LITTER, UNNECESSARY ARTICLES, CLEANING EQUIPMENT PROPERLY STORED - Comments: OBSERVED FOOD STORAGE RACKS STORED OUTSIDE. INSTRUCTED TO RELOCATE THE FOOD STORAGE RACKS INSIDE.

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.

APPROPRIATE METHOD OF HANDLING OF FOOD (ICE) HAIR RESTRAINTS AND CLEAN APPAREL WORN - Comments: OBSERVED FOOD HANDLERS IN PREP AREA WITH NO HAIR RESTRAINT. INSTRUCTED TO PROVIDE HAIR RESTRAINTS WHILE HANDLING FOOD AT ALL TIMES.

Unwashed produce can harbor pathogens and chemical residues.

Raw fruits and vegetables must be washed before use.

Wash thoroughly under running water; Before cutting, combining, cooking, or serving; Remove soil and contaminants.

APPROPRIATE METHOD OF HANDLING OF FOOD (ICE) HAIR RESTRAINTS AND CLEAN APPAREL WORN - Comments: OBSERVED FOOD HANDLERS IN PREP AREA WITH NO HAIR RESTRAINT. INSTRUCTED TO PROVIDE HAIR RESTRAINTS WHILE HANDLING FOOD AT ALL TIMES.

Unwashed produce can harbor pathogens and chemical residues.

Raw fruits and vegetables must be washed before use.

Wash thoroughly under running water; Before cutting, combining, cooking, or serving; Remove soil and contaminants.