QUON YICK FOOD CO. Fails Health Inspection - Chicago Bakery

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: OBSERVED NO WRITTEN EMPLOYEE HEALTH POLICY ON SITE. INSTRUCTED FACILITY TO ESTABLISH AN APPROPRIATE EMPLOYEE HEALTH POLICY AND MAINTAIN WITH VERIFIABLE SIGNED COPIES ON SITE FOR ALL FOOD EMPLOYEES IN ACKNOWLEDGMENT OF REPORTING AGREEMENT. PRIORITY FOUNDATION VIOLATION #7-38-010.

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: OBSERVED NO ADEQUATE SUPPLIES (DISPOSABLE MOP, DISPOSABLE LATEX GLOVES, DISPOSABLE MASK, AND ADEQUATE SANITIZER *MUST ELIMINATE NOROVIRUS*) ON SITE TO PROPERLY CLEAN UP ANY VOMIT OR DIARRHEA EVENTS THAT CAN POTENTIALLY OCCUR INSIDE OF THE FOOD ESTABLISHMENT. INSTRUCTED TO PROVIDE ADEQUATE SUPPLIES FOR VOMIT AND DIARRHEA CLEAN UP. PRIORITY FOUNDATION VIOLATION #7-38-005.

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

INSECTS, RODENTS, & ANIMALS NOT PRESENT - Comments: OBSERVED OVER 1,000 MOUSE DROPPINGS THROUGHOUT FACILITY IN THE FOLLOWING AREAS; IN CORNERS AND UNDER TABLES OF 1ST FLOOR PREP AREA, IN BASEMENT AREA UNDER AND BETWEEN BOXES STORED ON FLOOR, IN FAR REAR BASEMENT ROOM ON TOP OF AND AROUND PALLETS. INSTRUCTED PERSON IN CHARGE TO REMOVE ALL MOUSE DROPPINGS, SANITIZE ALL AREAS, AND INFORM PEST CONTROL OF NEED FOR ADDITIONAL SERVICE. PRIORITY VIOLATION #7-38-020(A). CITATION ISSUED.

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

INSECTS, RODENTS, & ANIMALS NOT PRESENT - Comments: OBSERVED 1/4IN GAP AT BOTTOM OF FRONT DOUBLE DOORS. INSTRUCTED PERSON IN CHARGE TO REPAIR AND MAINTAIN FOR THE PREVENTION OF PEST ACCESS.

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

INSECTS, RODENTS, & ANIMALS NOT PRESENT

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED CRATES BEING USED AS SHELVING THROUGHOUT PRODUCTION FLOOR. INSTRUCTED PERSON IN CHARGE TO REMOVE ALL PLASTIC MILK CRATES AND PROVIDE SHELVING

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: OBSERVED NO CHEMICAL TEST KIT AVAILABLE DURING INSPECTION. INSTRUCTED MANAGER TO PROVIDE TEST KIT FOR PROPER CONCENTRATION IN SANITIZING SOLUTIONS. PRIORITY FOUNDATION #7-38-005 CITATION ISSUED.

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: OBSERVED PIPE LEAKING EXCESSIVELY IN BASEMENT AREA CAUSING STANDING WATER. OBSERVED PIPES ALONG WALL BEHIND COOKING EQUIPMENT TO BE LEAKING. INSTRUCTED PERSON IN CHARGE TO REPAIR AND MAINTAIN.

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

TOILET FACILITIES: PROPERLY CONSTRUCTED, SUPPLIED, & CLEANED - Comments: OBSERVED NO COVERED RECEPTACLE IN UNISEX RESTROOM. INSTRUCTED PERSON IN CHARGE TO PROVIDE AND MAINTAIN COVERED RECEPTACLE FOR SANITARY PRODUCTS AT ALL TIMES.

Inadequate facilities lead to poor hygiene and contamination.

Toilet rooms must be properly equipped and maintained.

Self-closing doors; Toilet paper; Covered waste receptacles; Handwashing supplies; Cleaned regularly; Proper ventilation.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED EXCESSIVE CLUTTER IN BASEMENT AREA ROOMS ON FLOORS OF STORED CARDBOARD BOXES AND WOODEN PALLETS. INSTRUCTED PERSON IN CHARGE TO PROVIDE SHELVING TO MAINTAIN ITEMS AT LEAST SIX INCHES FROM FLOOR OR TO REMOVE.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED MISSING DRYWALL IN CEILING OF BASEMENT AREA NEAR STAIRS. INSTRUCTED PERSON IN CHARGE TO REPAIR AND MAINTAIN.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: OBSERVED EXCESSIVE DUST AND GRIME BUILD UP ON FILTERS IN HOOD SYSTEM. INSTRUCTED PERSON IN CHARGE TO CLEAN AND MAINTAIN.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: OBSERVED EXCESSIVE DUST AND GRIME BUILD UP ON FILTERS IN HOOD SYSTEM. INSTRUCTED PERSON IN CHARGE TO CLEAN AND MAINTAIN.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.