PROTEIN BAR Fails Health Inspection - Chicago Restaurant

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: FOUND PROCEDURE/PLAN ON SITE HOWEVER KIT NOT COMPLETE MISSING SOLUTION TO CONTROL NOROVIRUS FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS. INSTRUCTED FACILITY TO MAINTAIN ANY APPROPRIATE SUPPLIES ON SITE. PRIORITY FOUNDATION VIOLATION 7-38-005.

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: NO PAPER TOWELS PROVIDED AT HANDWASHING SINK AT DISHROOM AREA. PAPER TOWEL DISPENSER BROKEN,INSTRUCTED TO REPAIR CAUSE AND PROVIDE PAPER TOWEL AT SAID SINK. PRIORITY FOUNDATION VIOLATION:7-38-030(C)

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

PROPER DATE MARKING AND DISPOSITION - Comments: 3-501.17 - MUST PROVIDE PROPER LABELS FOR DATE MARKING THE PREPARATION AND CONSUME BY/DISCARD DATE (MAXIMUM OF 7 DAYS TOTAL) OF ALL REFRIGERATED, READY-TO-EAT, TCS FOODS PREPARED ON SITE AND HELD OVER 24HRS. PRIORITY FOUNDATION VIOLATION#: 7-38-005.

Inadequate reheating fails to kill bacteria that grew during storage.

Foods must be reheated to 165°F within 2 hours.

Reheat to 165°F within 2 hours; Use proper equipment (not hot holding units); Discard if not reaching temperature in time.

FOOD PROPERLY LABELED; ORIGINAL CONTAINER - Comments: NO LABEL ON CONTAINERS OF DRY FOOD, MUST PROVIDE LABEL WITH COMMON NAME

Missing allergen labeling can cause severe allergic reactions.

All food properly labeled with required information.

Common name; Ingredients; Allergen declarations; Date marking; Manufacturer info; Net quantity.

INSECTS, RODENTS, & ANIMALS NOT PRESENT - Comments: REAR EXIT DOOR WITH 1/2" GAP AT BOTTOM, INSTRUCTED TO REPAIR CAUSE TO MINIMIZE PEST ENTRY.

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: VENT COVER IN PREP AREA WITH DUST BUILD-UP,CLEAN AND MAINTAIN.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: LEAKING FAUCET(WEST AREA) AT FOUR COMPARTMENT SINK,ALSO AT PREP SINK .REPAIR AND MAINTAIN

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: UNABLE TO LOCATE BACK FLOW PREVENTION DEVICE PROVIDED AT ICE MACHINE WATER LINE,AT PREP/KITCHEN AREA. MUST INSTALL SO BACK FLOW PREVENTION DEVICE MAY BE LOCATED TO BE SERVICED AND MAINTAIN.

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

TOILET FACILITIES: PROPERLY CONSTRUCTED, SUPPLIED, & CLEANED - Comments: OBSERVED NO LIDDED TRASH CAN RECEPTACLE FOR DISPOSAL OF SANITARY ITEMS IN EMPLOYEES/CUSTOMER SHARED RESTROOM. INSTRUCTED MANAGER TO PROVIDE LIDDED TRASH CAN RECEPTACLE AT MENTIONED WASHROOM.MAINTAIN AT ALL TIMES

Inadequate facilities lead to poor hygiene and contamination.

Toilet rooms must be properly equipped and maintained.

Self-closing doors; Toilet paper; Covered waste receptacles; Handwashing supplies; Cleaned regularly; Proper ventilation.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: BROKEN WITH BLACK SLIME SUBSTANCE CAULKING ON WALL BEHIND THE FOUR COMPARTMENT SINK.REPAIR ,CLEAN AND MAINTAIN WITH A EASILY CLEANABLE SURFACE

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: NO PROTECTIVE SHIELD AT PREP AREA,INSTRUCTED TO PROVIDE

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ALLERGEN TRAINING AS REQUIRED - Comments: NO ALLERGEN TRAINING CERTIFICATES PROVIDED ON SITE. INSTRUCTED TO PROVIDE FOR ALL CERTIFIED FOOD SERVICE MANAGERS

Inadequate allergen knowledge can cause life-threatening allergic reactions.

Food allergen training required for certified managers.

Certified managers must complete allergen training; Staff must understand major allergens; Prevent cross-contact; Respond to customer inquiries.

ALLERGEN TRAINING AS REQUIRED - Comments: NO ALLERGEN TRAINING CERTIFICATES PROVIDED ON SITE. INSTRUCTED TO PROVIDE FOR ALL CERTIFIED FOOD SERVICE MANAGERS

Inadequate allergen knowledge can cause life-threatening allergic reactions.

Food allergen training required for certified managers.

Certified managers must complete allergen training; Staff must understand major allergens; Prevent cross-contact; Respond to customer inquiries.