POPEYES #2836 Fails Health Inspection - Chicago Restaurant

PREVIOUS MINOR VIOLATION(S) CORRECTED 7-42-090 - Comments: A separate and distinct offense shall be deemed to have been committed for each Minor violation that is not corrected upon re-inspection by the health authority. PREVIOUS MINOR VIOLATIONS FROM 10-19-09 #163322 NOT CORRECTED. #33-MUST DETAIL CLEAN WIRE STORAGE RACKS INSIDE THE WALK IN COOLER. #34-MAINTAIN THE FLOOR DRY IN THE REAR PREP AREA AND STORAGE ROOM. MISSING GROUT OF FLOORING IN BOTH AREAS AND AT DEEP FRYERS WITH POOLING WATER, MUST RE-GROUT. #35-OPEN GAPS IN THE STAINLESS STEEL WALLS BETWEEN THE DEEP FRYERS AND PREP TABLE AT CHICKEN PREP.MUST REPAIR SO THAT ALL WALLS ARE SMOOTH AND CLEANABLE, NO OPEN CRACKS, CREVICES.

Specialized processes without proper controls can create deadly toxins like botulism.

Special processes require approved HACCP plans or variances.

Written HACCP plan for: Vacuum packaging; Sous vide; Smoking for preservation; Curing; Using additives. Plan must be approved by CDPH.

This violation was corrected during the inspection.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: The floors shall be constructed per code, be smooth and easily cleaned, and be kept clean and in good repair. FLOOR BEHIND REAR HOT HOLDING BOX WITH FOOD DEBRIS, MUST CLEAN AND MAINTAIN.

Damaged floors harbor bacteria and create safety hazards.

Floors must be smooth, cleanable, and maintained.

Smooth, non-porous in food areas; Properly sloped to drains; Coving at wall junctures; Kept clean; Good repair.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: The walls and ceilings shall be in good repair and easily cleaned. WALL CAULKING CRACKED IN POOR REPAIR AT THREE AND ONE COMPARTMENT SINKS MUST REPLACE.

Damaged surfaces cannot be properly cleaned and may harbor pests.

Walls and ceilings must be smooth, cleanable, and in good repair.

Smooth, washable surfaces in food areas; Light colored; No holes or cracks; Clean and maintained.

LIGHTING: REQUIRED MINIMUM FOOT-CANDLES OF LIGHT PROVIDED, FIXTURES SHIELDED - Comments: Shielding to protect against broken glass falling into food shall be provided for all artificial lighting sources in preparation, service, and display facilities. MUST PROVIDE LIGHT SHIELDS OR SHATTER PROOF BULBS IN THE FOLLOWING AREAS, WALK IN COOLER, REAR DRY STORAGE, ABOVE COOKED CHICKEN IN FRONT HOT HOLDING.

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: Ventilation: All plumbing fixtures, such as toilets, sinks, washbasins, etc., must be adequately trapped, vented, and re-vented and properly connected to the sewer in accordance with the plumbing chapter of the Municipal Code of Chicago and the Rules and Regulations of the Board of Health. LEAK FROM PIPING UNDER THREE COMPARTMENT SINK, MUST REPAIR.

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: Ventilation: All plumbing fixtures, such as toilets, sinks, washbasins, etc., must be adequately trapped, vented, and re-vented and properly connected to the sewer in accordance with the plumbing chapter of the Municipal Code of Chicago and the Rules and Regulations of the Board of Health. LEAK FROM PIPING UNDER THREE COMPARTMENT SINK, MUST REPAIR.

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.