PILOT PROJECT BREWING Gets Conditional Pass on Health Inspection - Chicago Restaurant

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: OBSERVED BLANK COPIES OF EMPLOYEE HEALTH POLICY ON SITE. INSTRUCTED FACILITY TO MAINTAIN POLICY WITH VERIFIABLE SIGNED COPIES ON SITE FOR ALL FOOD EMPLOYEES IN ACKNOWLEDGMENT OF REPORTING AGREEMENT. PRIORITY FOUNDATION VIOLATION, #7-38-010.

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROPER COOLING METHODS USED; ADEQUATE EQUIPMENT FOR TEMPERATURE CONTROL - Comments: OBSERVED TWO (2) DOOR PREP COOLER IN MAIN KITCHEN TO CURRENTLY BE NOT FUNCTIONING CORRECTLY, WITH THE UNIT COLD HOLDING AT 52.7F. UNIT WAS NOT IN USE AT TIME OF INSPECTION, AND MANAGER STATED THEY ARE AWAITING REPAIRS FOR THE FOLLOWING DAY. OBSERVED THE EXTERIOR WALK IN BEER/DRINK COOLER TO BE UNDERGOING MAINTENANCE WHILE LINES ARE INSTALLED, AND IS CURRENTLY FUNCTIONING AT 70F. UNIT NOT IN USE AT THIS TIME. PREP TWO (2) DOOR COOLER AND WALK IN BEER/DRINK COOLER TAGGED AND HELD FOR INSPECTION AT THIS TIME. INSTRUCTED NOT TO USE BOTHG UNTIL COOLER/EQUIPMENT IS ABLE TO MAINTAIN TEMPERATURES OF AT LEAST 41F AND REINSPECTED BY CDPH. PRIORITY VIOLATION, 7-38-005.

Dirty equipment harbors bacteria and attracts pests.

All equipment and utensils must be clean and properly maintained.

Equipment clean to sight and touch; Free of food debris and grease; Maintained in good repair; Stored properly when clean.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED THE OVERHEAD EXHAUST SYSTEM TO HAVE A PROTECTIVE PLASTIC LAYER ON THE RIGHT SIDE THAT IS TORN AND PEELING. OBSERVED PROTECTIVE PLASTIC LAYER THAT IS TORN ON THE DOORS OF THE TWO DEEP FRYERS AND ON THE ICE BIN IN THE BASEMENT BAR AREA. INSTRUCTED MANAGER TO REMOVE AND PROVIDE A SMOOTH AND EASILY CLEANABLE SURFACE.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: OBSERVED THE HAND SINK IN THE DISH WASHING ROOM TO BE LEAKING ONTO THE FLOOR BELOW, CREATING A SMALL PUDDLE. INSTRUCTED TO SERVICE AND MAINTAIN IN GOOD REPAIR. OBSERVED THE LEFT SIDE HAND SINK IN THE WOMEN'S BATHROOM (ONE OF TWO SINKS) TO HAVE LOW WATER PRESSURE. INSTRUCTED MANAGER TO SERVICE AND PROVIDE ADEQUATE PRESSURE.

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

TOILET FACILITIES: PROPERLY CONSTRUCTED, SUPPLIED, & CLEANED - Comments: OBSERVED NO COVERED TRASH CANS IN THE WOMEN'S BATHROOM AT TIME OF INSPECTION. INSTRUCTED MANAGER TO PROVIDE A COVERED TRASH CAN IN ALL UNISEX AND FEMALE BATHROOMS.

Inadequate facilities lead to poor hygiene and contamination.

Toilet rooms must be properly equipped and maintained.

Self-closing doors; Toilet paper; Covered waste receptacles; Handwashing supplies; Cleaned regularly; Proper ventilation.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED CONDENSATE PIPE/EXPOSED PIPE DRIPPING ONTO THE FLOOR AND NOT INTO AN AVAILABLE FLOOR DRAIN BEHIND THE ICE MACHINE IN BASEMENT. INSTRUCTED MANAGER TO SERVICE AND DIRECT LINE TO ALLOW FOR APPROPRIATE DRAINAGE TO ELIMINATE ANY SPILLAGE.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: OBSERVED MECHANICAL VENTILATION IN THE MEN'S BATHROOM TO NOT BE FUNCTIONAL AT TIME OF INSPECTION. INSTRUCTED TO SERVICE AND MAINTAIN IN GOOD REPAIR TO PROVIDE ADEQUATE VENTILATION.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: OBSERVED MECHANICAL VENTILATION IN THE MEN'S BATHROOM TO NOT BE FUNCTIONAL AT TIME OF INSPECTION. INSTRUCTED TO SERVICE AND MAINTAIN IN GOOD REPAIR TO PROVIDE ADEQUATE VENTILATION.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.