Perkolator Fails Health Inspection - Chicago Restaurant

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: INSTRUCTED TO PROVIDE AND MAINTAIN HANDWASHING SIGNAGE AT HANDSINK AT FRONT COFFEE PREPARATION AREA.

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

FOOD-CONTACT SURFACES: CLEANED & SANITIZED - Comments: OBSERVED BLACK AND PINK SLIMY SUBSTANCES ON INTERIOR WATER COMPONENTS OF THE ICE MAKER,DRIPPING INTO ICE "ICE IS USED FOR HUMAN CONSUMPTION".MANAGEMENT WAS INSTRUCTED TO TURN OFF MACHINE, REMOVE ICE AND HAVE INTERIOR OF ICE MACHINE CLEANED AND SANITIZED AND MAINTAIN.PRIORITY FOUNDATION VIOLATION 7-38-005,CITATION ISSUED.

Dirty equipment harbors and spreads pathogens, causing cross-contamination and illness.

All food contact surfaces must be properly cleaned and sanitized.

Wash, rinse, sanitize after each use; Clean between different raw foods; Every 4 hours for continuous use; When contaminated; Proper procedures and chemicals.

PROPER COOLING METHODS USED; ADEQUATE EQUIPMENT FOR TEMPERATURE CONTROL - Comments: OBSERVED THE 3 DOOR PREP LINE COOLER WITH AN AIR TEMPERATURE OF 47.1F.NO (TCS FOODS) WERE FOUND IN MENTIONED COOLER AT THIS TIME OF INSPECTION.INSTRUCTED MANAGER COLD HOLDING UNIT MUST MAINTAIN COLD HOLDING TEMPERATURE OF 41.0F OR COLDER. INSTRUCTED TO REPAIR PREP LINE COOLER TAGGED "HELD FOR INSPECTION" AT THIS TIME.INSTRUCTED NOT TO USE UNTIL REPAIRED.SEE COMMENTS BELOW.PRIORITY VIOLATION 7-38-005,NO CITATION ISSUED.

Dirty equipment harbors bacteria and attracts pests.

All equipment and utensils must be clean and properly maintained.

Equipment clean to sight and touch; Free of food debris and grease; Maintained in good repair; Stored properly when clean.

THERMOMETERS PROVIDED & ACCURATE - Comments: INSTRUCTED TO PROVIDE AND MAINTAIN A VISIBLE ADEQUATE WORKING THERMOMETER FOR SMALL REFRIGERATOR BEHIND THE FRONT COUNTER SERVICE AREA.

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

FOOD PROPERLY LABELED; ORIGINAL CONTAINER - Comments: OBSERVED BULK CONTAINER IN REAR WITHOUT A LABEL.INSTRUCTED TO PROVIDE THE COMMON NAME ON ALL BULK CONTAINERS TO PROPERLY IDENTIFY ITEM (SALT, SUGAR, FLOUR ETC).

Missing allergen labeling can cause severe allergic reactions.

All food properly labeled with required information.

Common name; Ingredients; Allergen declarations; Date marking; Manufacturer info; Net quantity.

WIPING CLOTHS: PROPERLY USED & STORED - Comments: INSTRUCTED TO PROPERLY STORE ALL WASHCLOTHS IN A SANITIZING SOLUTION ESPECIALLY WHEN NOT IN USE.

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED STAINED CUTTING BOARD ON TOP OF THE 3-DOOR PREP LINE COOLER.INSTRUCTED TO RESURFACE OR REPLACE THE CUTTING BOARDS.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED STAINED CUTTING BOARD ON TOP OF THE 3-DOOR PREP LINE COOLER.INSTRUCTED TO RESURFACE OR REPLACE THE CUTTING BOARDS.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.