PAN Y PIZZA PA' YA Fails Health Inspection - Chicago Restaurant

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: OBSERVED NO WRITTEN EMPLOYEE HEALTH POLICY ON THE PREMISES.INSTRUCTED MANAGEMENT TO PROVIDE A SIGNED EMPLOYEE HEALTH POLICY FOR EACH EMPLOYEE.PRIORITY FOUNDATION VIOLATION 7-38-010.

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROPER COOLING METHODS USED; ADEQUATE EQUIPMENT FOR TEMPERATURE CONTROL - Comments: FOUND THE FOLLOWING REFRIGERATION UNIT IN KITCHEN PREP AREA NOT MAINTAINING PROPER TEMPERATURE:1 DOOR PREP LINE COOLER (AIR TEMPERATURE AT 49.0 F).INSTRUCTED MANAGER COLD HOLDING UNIT MUST MAINTAIN COLD HOLDING TEMPERATURE OF 41.0F OR COLDER. INSTRUCTED TO REPAIR AND MAINTAIN AS REQUIRED. PRIORITY VIOLATION 7-38-005.

Dirty equipment harbors bacteria and attracts pests.

All equipment and utensils must be clean and properly maintained.

Equipment clean to sight and touch; Free of food debris and grease; Maintained in good repair; Stored properly when clean.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED A TORN DOOR GASKETS INSIDE OF THE 3 DOOR AND THE 2 DOOR PREP LINE COOLERS.INSTRUCTED TO REPLACE THE TORN DOOR GASKETS AND MAINTAIN.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: OBSERVED LARGE BAKING MIXING BOWL AFFIXED, NOT DETACHABLE, LOCATED AT REAR NORTH-WEST PREP AREA TOO LARGE TO FULLY SUBMERGE IN EXISTING 3 COMPARTMENT SINKS TO PROPERLY WASH, RINSE AND SANITIZE. INSTRUCTED TO PROVIDE AND MAINTAIN PROCEDURES FOR ALTERNATIVE WAREWASHING OF MENTIONED BAKING MIXING EQUIPMENT.

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: BACKFLOW PREVENTION DEVICES NOT LOCATED AT ICE MACHINE,COFFEE/ESPRESSO MACHINE AND UTILITY MOP SINK.MUST INSTALL SO BACKFLOW PREVENTION DEVICES MAY BE LOCATED TO BE SERVICED AND MAINTAINED.

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: A MINIMUM OF ONE SINK USED FOR FOOD PREPARATION,OBTAINING WATER,AND DISCARDING LIQUID WASTE IS REQUIRED AT FRONT COFFEE/FOOD PREPARATION AREA.

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

SEWAGE & WASTE WATER PROPERLY DISPOSED - Comments: OBSERVED WASTE WATER BACKING UP FROM THE GREASE TRAP BOX UNDERNEATH THE DISHWASHING 3-COMPARTMENT SINK WHEN THE WATER IS FILLED AND RELEASED FROM THE MIDDLE COMPARTMENT.INSTRUCTED TO REPAIR PLUMBING ISSUE AND MAINTAIN AS REQUIRED. PRIORITY VIOLATION 7-38-030 (C).

Improper disposal contaminates environment and attracts pests.

All waste water must be properly disposed.

Discharge to approved sewer; No dumping outside; Grease trap maintained; No floor draining to exterior.

TOILET FACILITIES: PROPERLY CONSTRUCTED, SUPPLIED, & CLEANED - Comments: OBSERVED NO COVERED WASTE RECEPTACLE PROVIDED IN THE EMPLOYEE UNISEX WASHROOM. MUST PROVIDE AND MAINTAIN.

Inadequate facilities lead to poor hygiene and contamination.

Toilet rooms must be properly equipped and maintained.

Self-closing doors; Toilet paper; Covered waste receptacles; Handwashing supplies; Cleaned regularly; Proper ventilation.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: OBSERVED MECHANICAL VENTILATION NOT WORKING INSIDE THE EMPLOYEE UNISEX WASHROOM .INSTRUCTED TO REPAIR AND MAINTAIN MECHANICAL VENTILATION IN WASHROOM.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: OBSERVED MECHANICAL VENTILATION NOT WORKING INSIDE THE EMPLOYEE UNISEX WASHROOM .INSTRUCTED TO REPAIR AND MAINTAIN MECHANICAL VENTILATION IN WASHROOM.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.