OUTPUT Gets Conditional Pass on Health Inspection - Chicago Restaurant

SOURCE OF CROSS CONTAMINATION CONTROLLED I.E. CUTTING BOARDS, FOOD HANDLERS, UTENSILS, ETC - Comments: All food shall be protected from contamination and the elements, and so shall all food equipment, containers, utensils, food contact surfaces and devices, and vehicles. NO PAPER TOWELS AT EXPOSED HAND SINK AT INITIAL INSPECTION. OBSERVE EMPLOYEE ON COOKS LINE WEARING GLOVES THEN KNEELING DOWN AND TOUCHING THE FLOOR THEN PROCEED TO TOUCH FOOD CONTAINERS ON COOKS LINE. THEN INSTRUCTED SAME EMPLOYEE TO WASH HANDS AND OBSERVED EMPLOYEE USE DIRTY APRON TO DRY HANDS.

These activities introduce saliva and contaminants into food areas, potentially spreading bacteria and viruses to customers.

Food employees must not eat, drink, or use tobacco in food preparation areas.

Eating, drinking, tobacco use only in designated areas; Closed beverage containers with straw allowed in some areas; Proper tasting using clean utensil each time; No personal items in food prep areas.

SANITIZING RINSE FOR EQUIPMENT AND UTENSILS: CLEAN, PROPER TEMPERATURE, CONCENTRATION, EXPOSURE TIME - Comments: Equipment and utensils should get proper exposure to the sanitizing solution during the rinse cycle. Bactericidal treatment shall consist of exposure of all dish and utensil surfaces to a rinse of clean water at a temperature of not less than 180F. CHEMICAL DISH MACHINE NOT PROPERLY SANITIZING WHILE DISHES BEING WASHED. FOUND CHLORINE LEVEL TO BE 0PPM AFTER SEVERAL ATTEMPTS. MACHINE TAGGED HELD FOR INSPECTION AND MUST NOT USE UNTIL REPAIRED AND MAINTAINS TEMPERATURE OF 100PPM. FAX REQUEST FOR INSPECTION AND TAG REMOVAL TO 312-746-4240, SUPERVISOR LOPEZ.

Improper sanitization fails to kill pathogens, allowing contaminated equipment to spread illness throughout facility.

Sanitizing solutions and rinse water must meet specific requirements for effectiveness.

Chemical sanitizers: Chlorine 50-100 ppm, Quaternary ammonium 200-400 ppm, Iodine 12.5-25 ppm; Hot water: 171°F for 30 seconds or 180°F at dish surface; Test strips required; Proper contact time.

FOOD IN ORIGINAL CONTAINER, PROPERLY LABELED: CUSTOMER ADVISORY POSTED AS NEEDED - Comments: All food not stored in the original container shall be stored in properly labeled containers. PREPARED CHICKEN WINGS IN WALK-IN COOLER MUST BE DATED PROPERLY.

Improper methods result in slow cooling that allows bacterial growth.

Approved cooling methods must be used.

Use shallow pans, ice baths, rapid chill units, ice wands; Cut large items into smaller portions; Stir frequently; Leave uncovered during cooling.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: All food and non-food contact equipment and utensils shall be smooth, easily cleanable, and durable, and shall be in good repair. MUST NOT USE TIN FOIL AS LINER FOR SHELVING THROUGHOUT KITCHEN.

Unapproved processes may lack critical safety controls.

Variance required before conducting specialized food processes.

Submit application to CDPH; Include HACCP plan; Await approval before starting; Maintain all required records.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: The floors shall be constructed per code, be smooth and easily cleaned, and be kept clean and in good repair. TILE FLOORS ON COOKS LINE CRACKED, DAMAGED. MUST REPAIR/REPLACE. MUST REMOVE POOLING WATER FROM BASEMENT FLOOR AND WATER FROM METAL PAN ON FLOOR IN BASEMENT.

Damaged floors harbor bacteria and create safety hazards.

Floors must be smooth, cleanable, and maintained.

Smooth, non-porous in food areas; Properly sloped to drains; Coving at wall junctures; Kept clean; Good repair.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: The walls and ceilings shall be in good repair and easily cleaned. WATER DAMAGED CEILING TILES ABOVE KITCHEN THREE COMPARTMENT SINK AND ICE MACHINE. MUST REPLACE.

Damaged surfaces cannot be properly cleaned and may harbor pests.

Walls and ceilings must be smooth, cleanable, and in good repair.

Smooth, washable surfaces in food areas; Light colored; No holes or cracks; Clean and maintained.

LIGHTING: REQUIRED MINIMUM FOOT-CANDLES OF LIGHT PROVIDED, FIXTURES SHIELDED - Comments: All rooms in which food or drink is prepared, or in which utensils are washed, shall be lighted so that a minimum of 50-foot candles of light is available on all work surfaces. MUST PROVIDE LIGHT INSIDE WALK-IN FREEZER.

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: Ventilation: All plumbing fixtures, such as toilets, sinks, washbasins, etc., must be adequately trapped, vented, and re-vented and properly connected to the sewer in accordance with the plumbing chapter of the Municipal Code of Chicago and the Rules and Regulations of the Board of Health. MUST PROVIDE DRAINAGE TUBING FOR BAR SODA GUN HOLDER.

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

REFRIGERATION AND METAL STEM THERMOMETERS PROVIDED AND CONSPICUOUS - Comments: All food establishments that display, prepare, or store potentially hazardous foods shall have calibrated metal stem thermometers, provided and conspicuous, for refrigerated and hot food units. MUST PROVIDE FOR WALK-IN FREEZER.

Poor personal hygiene transfers contaminants to food.

Food handlers must maintain personal cleanliness.

Clean outer clothing; Hair restraints; Short, clean fingernails; No jewelry except plain ring; Clean hands and arms.

APPROPRIATE METHOD OF HANDLING OF FOOD (ICE) HAIR RESTRAINTS AND CLEAN APPAREL WORN - Comments: All employees must wear garments that are clean and of washable character and nature. All employees shall be required to use effective hair restraints to confine hair. ALL EMPLOYEES MUST WEAR HAT/HAIR RESTRAINTS.

Unwashed produce can harbor pathogens and chemical residues.

Raw fruits and vegetables must be washed before use.

Wash thoroughly under running water; Before cutting, combining, cooking, or serving; Remove soil and contaminants.

APPROPRIATE METHOD OF HANDLING OF FOOD (ICE) HAIR RESTRAINTS AND CLEAN APPAREL WORN - Comments: All employees must wear garments that are clean and of washable character and nature. All employees shall be required to use effective hair restraints to confine hair. ALL EMPLOYEES MUST WEAR HAT/HAIR RESTRAINTS.

Unwashed produce can harbor pathogens and chemical residues.

Raw fruits and vegetables must be washed before use.

Wash thoroughly under running water; Before cutting, combining, cooking, or serving; Remove soil and contaminants.