NUEVO LEON RESTAURANT Fails Health Inspection - Chicago Restaurant

PROPER COLD HOLDING TEMPERATURES - Comments: OBSERVED TCS FOODS AT IMPROPER TEMPERATURE REQUIREMENT STORED IN SANDWICH PREP COOLER. FOUND INTERNAL TEMPERATURE OF THE FOLLOWING FOOD PRODUCTS. SLICED BEEF AT 50.3F, CHICKEN AT 49.9F AND EGGS AT 59.8F INSTRUCTED ALL TCS FOODS MUST MAINTAIN COLD HOLDING TEMPERATURE OF BELOW 41.0F AND HOT HOLDING TEMPERATURE OF ABOVE 135.0F. OPERATOR VOLUNTARILY DISCARDED AND DENATURED FOODS DURING INSPECTION. PRIORITY VIOLATIONI 7-38-005. CITATION ISSUED.

Temperatures below 135°F allow bacteria to multiply, especially spore-formers that survive cooking.

Hot foods must be held at 135°F or above.

Maintain 135°F or above; Check temperatures regularly; Proper hot holding equipment; Cannot reheat in hot holding units.

PROPER DATE MARKING AND DISPOSITION - Comments: OBSERVED TCS FOODS (COOKED CHICKEN, COOKED PORK AND COOKED BEEF) HELD FOR OVER 24 HOURS WITH OUT DISCARD DATES. INSTRUCTED FACILITY TO PROVIDE DISCARD DATE FOR ANY TCS FOODS HELD FOR OVER 24 HOURS. PRIORITY FOUNDATION 7-38-005. CITATION ISSUED.

Inadequate reheating fails to kill bacteria that grew during storage.

Foods must be reheated to 165°F within 2 hours.

Reheat to 165°F within 2 hours; Use proper equipment (not hot holding units); Discard if not reaching temperature in time.

PROPER COOLING METHODS USED; ADEQUATE EQUIPMENT FOR TEMPERATURE CONTROL - Comments: OBSERVED 2 DOOR COOLER NOT MAINTAINING PROPER TEMPERATURE 49.2F. INSTRUCTED MANAGER TO REPAIR AND MAINTAIN COOLER AT 41F OR BELOW. PRIORITY 7-38-005 CITATION ISSUED. ENGINEER ARRIVED ON SITE TO FIX IT

Dirty equipment harbors bacteria and attracts pests.

All equipment and utensils must be clean and properly maintained.

Equipment clean to sight and touch; Free of food debris and grease; Maintained in good repair; Stored properly when clean.

FOOD PROPERLY LABELED; ORIGINAL CONTAINER - Comments: OBSERVED BLACK PEPPER, SALT AND SUGAR OUT OF THE ORIGINAL CONTAINERS WITHOUT LABELS CONTAINING THE PRODUCT NAME. INSTRUCTED TO LABEL ALL FOODS AND SPICES WITH COMMON NAME THAT ARE OUT OF THE ORIGINAL CONTAINERS.

Missing allergen labeling can cause severe allergic reactions.

All food properly labeled with required information.

Common name; Ingredients; Allergen declarations; Date marking; Manufacturer info; Net quantity.

CONTAMINATION PREVENTED DURING FOOD PREPARATION, STORAGE & DISPLAY - Comments: OBSERVED FOOD ITEMS STORED ON FLOOR IN WALK-IN COOLERS. INSTRUCTED MANAGER TO ELEVATE ALL FOOD SIX INCHES OFF FLOOR.

Contamination during preparation is a leading cause of foodborne illness.

Prevent contamination during all food handling.

Minimize bare hand contact; Prevent cross-contamination; Use clean equipment; Proper employee hygiene.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED CARDBOARD USED AS LINER IN WALK IN COOLER. INSTRUCTED MANAGER TO REMOVE ALL CARDBOARD FROM SHELVING UNITS. ALL FOOD AND NON-FOOD CONTACT SURFACES MUST BE SMOOTH AND EASILY CLEANABLE.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: NOTED SOME USE OF MILK CRATES FOR ELEVATION AT THE KITCHEN AREA, AND DRY STORAGE AREA. INSTRUCTED NOT TO USE MILK CRATES FOR ELEVATION TO PREVENT HIDING PLACES FOR PEST. MUST PROVIDE APPROPRIATE SHELVING FOR STORAGE. ALL FOOD ITEMS MUST ALSO BE STORED 6" AWAY FROM THE WALL

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED TORN/DAMAGED RUBBER GASKET ON DOOR OF THE FREEZER AND THE TWO DOOR COOLER ; INSTRUCTED TO REPAIR OR REPLACE GASKET.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: MUST CLEAN GREASE AND FOOD DEBRIS BUILD UP FROM FRYER CABINETS,OVEN,GRILL TABLE,REACH IN AND WALK IN COOLERS AND REACH IN FREEZERS,LIGHT SHIELDS IN PREP AREA.MUST DEFROST CHEST FREEZERS.

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

TOILET FACILITIES: PROPERLY CONSTRUCTED, SUPPLIED, & CLEANED - Comments: FOUND NO COVERED WASTE RECEPTACLE IN WOMENS WASHROOM; MUST PROVIDE FOR FEMININE PRODUCTS. MUST PROVIDE GARBAGE CANS IN EMPLOYEES MEN TOILET ROOM

Inadequate facilities lead to poor hygiene and contamination.

Toilet rooms must be properly equipped and maintained.

Self-closing doors; Toilet paper; Covered waste receptacles; Handwashing supplies; Cleaned regularly; Proper ventilation.

TOILET FACILITIES: PROPERLY CONSTRUCTED, SUPPLIED, & CLEANED - Comments: OBSERVED WASHROOM DOORS NOT SELF-CLOSING. INSTRUCTED MANAGER TO REPAIR SELF-CLOSING DEVICE ON WASHROOM DOOR.

Inadequate facilities lead to poor hygiene and contamination.

Toilet rooms must be properly equipped and maintained.

Self-closing doors; Toilet paper; Covered waste receptacles; Handwashing supplies; Cleaned regularly; Proper ventilation.

GARBAGE & REFUSE PROPERLY DISPOSED; FACILITIES MAINTAINED - Comments: OBSERVED OUTSIDE GARBAGE DUMPSTER LID MISSING AND DEBRIS AROUND DUMPSTER. MUST REPLACE LIDS TO BE TIGHT FITTING. KEEP AREA CLEAN. (PRIORITY FOUNDATION 7-38-020(B)(CITATION ISSUED)

Poor waste management attracts pests and creates contamination sources.

Refuse must be properly contained and removed.

Leak-proof, pest-proof containers; Tight-fitting lids; Clean storage areas; Frequent removal; Containers cleaned.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: MUST DETAIL CLEAN GREASE AND FOOD DEBRIS FROM FLOORS UNDER HEAVY EQUIPMENT IN PREP AREA. ALSO,CLEAN DEBRIS FROM FLOORS IN WALK-IN COOLERS. INSTRUCTED TO CLEAN AND MAINTAIN.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: INSTRUCTED TO CLEAN FLOORS, WALLS AND CEILINGS IN KITCHEN AREAS TO REMOVE GREASE AND SPLATTER. CLEAN FLOOR IN STORAGE AREAS.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: INSTRUCTED TO CLEAN THE VENTS IN THE HOODED SYSTEM ABOVE THE GRILL IN THE KITCHEN AREA.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: INSTRUCTED TO CLEAN THE VENTS IN THE HOODED SYSTEM ABOVE THE GRILL IN THE KITCHEN AREA.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.