NEW NAAN ON DEVON & GRILL Fails Health Inspection - Chicago Restaurant

HAND WASHING FACILITIES: WITH SOAP AND SANITARY HAND DRYING DEVICES, CONVENIENT AND ACCESSIBLE TO FOOD PREP AREA - Comments: OBSERVED ONLY EXPOSED HAND WASHING SINK IN KITCHEN NOT ACCESSIBLE WITH LARGE BOWL WITHIN SINK AND LARGE POTS OF FOOD BLOCKING SINK FROM BEING USED. SINK WAS MADE FULLY ACCESSIBLE DURING INSPECTION. CRITICAL VIOLATION 7-38-030

Missing supplies prevent proper handwashing, forcing inadequate cleaning that spreads pathogens.

All handwashing sinks must have soap and hand drying provisions.

Soap in dispensers at each sink; Paper towels in dispensers or air dryers; Supplies maintained during all hours; Waste receptacles if paper towels used.

NO EVIDENCE OF RODENT OR INSECT OUTER OPENINGS PROTECTED/RODENT PROOFED, A WRITTEN LOG SHALL BE MAINTAINED AVAILABLE TO THE INSPECTORS - Comments: OBSERVED 2 LIVE COKROACHES IN EXPOSED HAND WASHING SINK. OBSERVED LIVE COCKROACH INSIDE SMALL REFRIGERATION UNIT. OBSERVED 3 LIVE COCKROACHES INSIDE MECHANICAL PANEL OF SAME REFRIGERATOR. OBSERVED LARGE LIVE COKROACH ON KITHCEN FLOOR. MUST ELIMINATE ALL COKROACH ACTIVITY SERIOUS VIOALTION 7-38-020

Unprotected openings allow pest entry, leading to contamination of food and surfaces.

Building openings must be protected against pest entry.

Doors tight-fitting and self-closing; Windows screened; Openings sealed; Pest control log maintained; Regular monitoring; Professional service when needed.

* CERTIFIED FOOD MANAGER ON SITE WHEN POTENTIALLY HAZARDOUS FOODS ARE PREPARED AND SERVED - Comments: OBSERVED NO CITY OF CHICAGO CERTIFIED FOOD MANAGER ON SITE WHILE POTENTIALLY HAZARDOUS FOOD IS BEING PREPARRED COOKED AND SERVED INCLUDING BEEF AND CHICKEN. SERIOUS VIOLATION 7-38-012

Temperatures above 41°F allow rapid bacterial multiplication, doubling every 20 minutes.

Cold foods must be held at 41°F or below.

Maintain 41°F or below; Check temperatures regularly; Properly functioning refrigeration; Thermometers in all units; Keep doors closed.

PREVIOUS MINOR VIOLATION(S) CORRECTED 7-42-090 - Comments: OBSERVED PREVIOUS MINOR VIOLATIONS FROM REPORT DATED 8/23/16 INSPECTION #1951045 NOT CORRECTED INCLUDING #30 OBSERVED NO LABELS OF PREPARRED FOOD IN WALK IN COOLERS. MUST LABEL AND DATE ALL PREPARRED FOOD OUT OF ITS ORIGINAL CONTAINER IN WALK IN COOLER AND ALL REACH IN REFRIGERAROS. OBSERVED PREPACKAGED ITEMS THAT NEED LABEL CONTAINING : NAME OF PRODUCT, ADDRESS OF RESTAURNAT AND INGREDIENTS OF PRODUCT. #32 OBSERVED ALL PLATES AND POTS AND PANS STORED RIGHT SIDE UP. ALL PLATES AND POTS AND PANS MUST BE STORED INVERTED TO PREVENT DUST OR DIRT. #33 OBSERVED THE FOLLOWING AREAS UNCLEAN WITH DIRT, GREASE AND FOOD SPILLLS: INTERIOR OF REACH IN REFRIGERATORS, MICROWAVES, INTERIOR OF NON WORKING REFIRGERATORS USED FOR DRY STORAGE, ALL SHLEVES OF WALK IN COOLER, ALL SHELVES OF REACH IN COOLERS, ALL FOOD STROAGE SHELVING AND SHELVING FOR GLASSWARE AND PLATES. CLEAN SHELVES AVOVE 3 COMPARTMENT SINK. OBSERVED LARGE STANDUP MIXER UNCLEAN. CLEAN AND MAINTAIN LARGE STAND UP MIXER.#34 OBSERVED FLOORS UNCLEAN WITH BUILD UP OF DIRT, DEBRIS AND GREASE UNDER SHELVES NEAR EXPOSED HAND SINK , NEAR 3 COMPARTMENT SINK AND MOP SINK. OBSERVED HEAVY GREASE ACCUMULATION BEHIND ALL COOKING AREAS. MUST CLEAN ALL FLOORS IN DETAILS ALONG WALLS UNDER AND BEHIND ALL LARGE EQUIPMENT AND MAINTAIN. OBSERVED BASEBOARDS IN DISREPAIR UNDER 3 COMPARTMENT SINK AND NEAR MOP SINK. MUST REATTACH ALL BASEBOARDS AND MAINTAIN. OBSERVED DIRT GREASE AND GRIME BUILT UP IN CORNERS AND ALONG WALLS. CLEAN FLOORS IN DETAIL AND MAINTAIN. ALL PREVIOUS MINOR VIOLATIONS MUST BE CORRECTED AND MAINTAINED. SERIOUS VIOLATION 7-42-090

Specialized processes without proper controls can create deadly toxins like botulism.

Special processes require approved HACCP plans or variances.

Written HACCP plan for: Vacuum packaging; Sous vide; Smoking for preservation; Curing; Using additives. Plan must be approved by CDPH.

This violation was corrected during the inspection.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: ALL BASEBOARD COVING NEEDS TO BE REPLACED AROUND MOP SINK AND UNDER 3 COMPARTMENT SINK. SEAL ALL HOLES IN WALLS TO PREVENT THE ENTRY OF COCKROACKES.

Damaged floors harbor bacteria and create safety hazards.

Floors must be smooth, cleanable, and maintained.

Smooth, non-porous in food areas; Properly sloped to drains; Coving at wall junctures; Kept clean; Good repair.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: OBSERVED WALLS UNCLEAN. SOUTH WALL INBETWEEN REAR EXIT DOOR AND WALK IN COOLER DOOR WITH HEAVY ACCUMULATION OF FOOD SPLATTER. OBSERVED EAST WALL BEHIND ALL COOKING EQUIPMENT UNCLEAN WITH HEAVY ACCUMULAITON OF FOOD SPLATTER. MUST CLEAN ALL WALLS AND MAINTAIN. ALL WALLS AND ALONG ALL BASEBOARDS UNDER 3 COMPARTENT SINK AND NEAR MOP SINK MUST BE CLEANED IN DETAIL. OBSERVED OUTLET COVER BROKEN. REPLACED BROKE OUTLET COVER UNDER 3 COMPARTMENT SINK. OBSERVED HOLE IN CEILING AROUND PIPES NEAR WALK IN COOLER. HOLE MUST BE SEALED TO RPEVENT PEST ENTRY. OBSERVED VENT IN MENS WASHROOM WITH HEAVY DUST ACCUMUALTION. CLEAN AND MAINTAIN.

Damaged surfaces cannot be properly cleaned and may harbor pests.

Walls and ceilings must be smooth, cleanable, and in good repair.

Smooth, washable surfaces in food areas; Light colored; No holes or cracks; Clean and maintained.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: OBSERVED WALLS UNCLEAN. SOUTH WALL INBETWEEN REAR EXIT DOOR AND WALK IN COOLER DOOR WITH HEAVY ACCUMULATION OF FOOD SPLATTER. OBSERVED EAST WALL BEHIND ALL COOKING EQUIPMENT UNCLEAN WITH HEAVY ACCUMULAITON OF FOOD SPLATTER. MUST CLEAN ALL WALLS AND MAINTAIN. ALL WALLS AND ALONG ALL BASEBOARDS UNDER 3 COMPARTENT SINK AND NEAR MOP SINK MUST BE CLEANED IN DETAIL. OBSERVED OUTLET COVER BROKEN. REPLACED BROKE OUTLET COVER UNDER 3 COMPARTMENT SINK. OBSERVED HOLE IN CEILING AROUND PIPES NEAR WALK IN COOLER. HOLE MUST BE SEALED TO RPEVENT PEST ENTRY. OBSERVED VENT IN MENS WASHROOM WITH HEAVY DUST ACCUMUALTION. CLEAN AND MAINTAIN.

Damaged surfaces cannot be properly cleaned and may harbor pests.

Walls and ceilings must be smooth, cleanable, and in good repair.

Smooth, washable surfaces in food areas; Light colored; No holes or cracks; Clean and maintained.