MONTERREY BAKERY Gets Conditional Pass on Health Inspection - Chicago Bakery

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: NO EMPLOYEE HEALTH IN POLICY. INSTD TO PROVIDE EMPLOYEE HEALTH POLICY IN PLACE AND MAINTAIN. PRIORITY FOUNDATION 7-38-010.

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: NO PROCEDURE IN PLACE FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS. INSTD TO PROVIDE AND MAINTAIN SAME. PRIORITY FOUNDATION 7-38-005.

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: NO HANDWASH SIGNAGE AT HANDWASH SINKS. INSTD TO PROVIDE SIGNAGE.

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

PROPER DATE MARKING AND DISPOSITION - Comments: REFRIGERATED CAKES NOT PROPERLY LABELED OR DATED. REFRIGERATED, READY TO EAT TCS FOOD PREPARED AND HELD FOR MORE THAN 24 HOURS SHALL BE CLEARLY MARKED TO INDICATE THE DAY OR DATE BY WHICH FOOD SHALL BE SOLD OR DISCARDED FOR A MAXIMUM OF 7 DAYS. PRIORITY FOUNDATION VIOLATION 7-38-005.

Inadequate reheating fails to kill bacteria that grew during storage.

Foods must be reheated to 165°F within 2 hours.

Reheat to 165°F within 2 hours; Use proper equipment (not hot holding units); Discard if not reaching temperature in time.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: WORN WOOD SURFACE ON BOTTOM OF PREP TABLE. INSTD TO SEAL AND MAINTAIN SAME.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

TOILET FACILITIES: PROPERLY CONSTRUCTED, SUPPLIED, & CLEANED - Comments: MISSING COVERED RECEPTACLE IN TOILET ROOM. INSTD TO PROVIDE AND MAINTAIN.

Inadequate facilities lead to poor hygiene and contamination.

Toilet rooms must be properly equipped and maintained.

Self-closing doors; Toilet paper; Covered waste receptacles; Handwashing supplies; Cleaned regularly; Proper ventilation.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: EXCESSIVE CLUTTER/UNUNSED EQUIPMENT IN OUTISDE REAR. INSTD TO REMOVE ALL AND MAINTAIN AREA CLEAN. CEILING THROUGH OUT WITH WORN AND STAINED SURFACE. INSTD TO PAINT AND MAINTAIN SAME.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: MISSING OUTLET COVER IN TOILET ROOM. FLOOR DRAIN COVER MISSING IN BASEMENT. INSTD TO PROVIDE AND MAINTAIN.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: MISSING OUTLET COVER IN TOILET ROOM. FLOOR DRAIN COVER MISSING IN BASEMENT. INSTD TO PROVIDE AND MAINTAIN.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.