ML KITCHEN INC. Fails Health Inspection - Chicago Restaurant

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: OBSERVED MISSING HANDWASH SIGNAGE AT FRONT SMOOTHIE BAR HANDSINK. INSTRUCTED TO INSTALL AND MAINTAIN.

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

PROPER COLD HOLDING TEMPERATURES - Comments: OBSERVED TCS FOODS HELD AT IMPROPER INTERNAL TEMPERATURES IN THE REAR PREP COLD HOLDING UNIT, SUCH AS 10 LBS OF CHICKEN AT 50.1F, 2 LBS OF SHRIMP AT 48.3F, AND 2 LBS OF EGG ROLLS AT 48.5F. THE MANAGER DISCARDED AND DENATURED A TOTAL OF 14 LBS AT $150. ALL COLD TCS FOOD MUST MAINTAIN 41F OR BELOW. PRIORITY VIOLATION. CITATION ISSUED 7-38-005.

Temperatures below 135°F allow bacteria to multiply, especially spore-formers that survive cooking.

Hot foods must be held at 135°F or above.

Maintain 135°F or above; Check temperatures regularly; Proper hot holding equipment; Cannot reheat in hot holding units.

FOOD PROPERLY LABELED; ORIGINAL CONTAINER - Comments: OBSERVED FOOD STORAGE CONTAINERS WITHOUT LABELS CONTAINING THE COMMON NAME OF FOODS. INSTRUCTED TO PROVIDE.

Missing allergen labeling can cause severe allergic reactions.

All food properly labeled with required information.

Common name; Ingredients; Allergen declarations; Date marking; Manufacturer info; Net quantity.

CONTAMINATION PREVENTED DURING FOOD PREPARATION, STORAGE & DISPLAY - Comments: OBSERVED FOOD CONTAINERS STORED ON THE FLOOR IN THE WALK-IN COOLER, FREEZER, PREP, AND STORAGE AREAS. INSTRUCTED MANAGER TO PROPERLY STORE AND PROTECT FOOD ITEMS FROM CONTAMINATION WHILE STORED BY ELEVATING AT LEAST SIX INCHES FROM THE FLOOR ON RAISED SHELVING UNITS.

Contamination during preparation is a leading cause of foodborne illness.

Prevent contamination during all food handling.

Minimize bare hand contact; Prevent cross-contamination; Use clean equipment; Proper employee hygiene.

PERSONAL CLEANLINESS - Comments: OBSERVED FOOD HANDLERS PREPPING FOOD WITHOUT HAIR RESTRAINTS. INSTRUCTED PERSON IN CHARGE THAT ALL FOOD HANDLERS MUST WEAR A HAIR RESTRAINT.

Poor personal hygiene transfers contaminants to food.

Food handlers must maintain personal cleanliness.

Clean outer clothing; Hair restraints; Short, clean fingernails; No jewelry except plain ring; Clean hands and arms.

WIPING CLOTHS: PROPERLY USED & STORED - Comments: OBSERVED WET WIPING CLOTHS ON SEVERAL PREP SURFACE AREAS. INSTRUCTED TO PROPERLY STORE WIPING CLOTHS IN A SANITIZING SOLUTION BETWEEN USES TO PREVENT CONTAMINATION OF EQUIPMENT & FOOD. MUST MAINTAIN

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED GREASE BUILDUP, FOOD DEBRIS, AND DIRT ON THE FLOOR UNDER COOKING EQUIPMENT, ALONG WALLS, AND IN ALL CORNERS IN PREP, DISHWASHING, STORAGE, AND BASEMENT AREAS. INSTRUCTED MANAGER TO CLEAN FLOORS UNDER ALL EQUIPMENT, ALONG WALLS, AND ALL CORNERS IN ALL AREAS. OBSERVED DUST BUILDUP ON THE FAN IN THE WALK-IN COOLER, LIGHT SHIELDS IN THE COOKING AREA, AND CEILING AND WALL VENTS IN PREP AND STORAGE AREAS. INSTRUCTED MANAGER TO CLEAN AND MAINTAIN ALL FANS, LIGHT SHIELDS, AND CEILING/WALL VENTS.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED GREASE BUILDUP, FOOD DEBRIS, AND DIRT ON THE FLOOR UNDER COOKING EQUIPMENT, ALONG WALLS, AND IN ALL CORNERS IN PREP, DISHWASHING, STORAGE, AND BASEMENT AREAS. INSTRUCTED MANAGER TO CLEAN FLOORS UNDER ALL EQUIPMENT, ALONG WALLS, AND ALL CORNERS IN ALL AREAS. OBSERVED DUST BUILDUP ON THE FAN IN THE WALK-IN COOLER, LIGHT SHIELDS IN THE COOKING AREA, AND CEILING AND WALL VENTS IN PREP AND STORAGE AREAS. INSTRUCTED MANAGER TO CLEAN AND MAINTAIN ALL FANS, LIGHT SHIELDS, AND CEILING/WALL VENTS.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.