MAXWELL CHARCOAL GRILL Gets Conditional Pass on Health Inspection - Chicago Restaurant

PERSON IN CHARGE PRESENT, DEMONSTRATES KNOWLEDGE, AND PERFORMS DUTIES - Comments: PIC DOESN'T HAVE A CERTIFIED FOOD MANAGERS CERTIFICATE. MUST PROVIDE AND MAINTAIN.(PRIORITY FOUNDATION 7-38-012)

Without knowledgeable supervision, critical food safety practices may be overlooked, significantly increasing risk of foodborne illness outbreaks affecting multiple customers.

The person in charge must be present during all hours of operation, hold valid certification, and demonstrate food safety knowledge.

Person in charge must: Be present during all operating hours; Hold valid City of Chicago Food Service Sanitation Certificate; Demonstrate knowledge of foodborne disease prevention, HACCP principles, and Code requirements; Ensure employee compliance with food safety practices.

CITY OF CHICAGO FOOD SERVICE SANITATION CERTIFICATE - Comments: OBSERVED NO CERTIFIED FOOD MANAGER ON DUTY WHILE TCS FOODS ARE BEING PREPARED,HANDLED AND SERVED SUCH AS (SAUSAGE,EGGS,ITALIAN BEEF,ETC)MUST BE ON SITE AT ALL TIMES. MANAGER ARRIVED ON SITE AT 11:15 A.M.(COS)(PRIROITY FOUNDATION 7-38-012)(CITATION ISSUED)

Lack of certification indicates potential gaps in food safety knowledge, increasing risk of improper food handling and foodborne illness.

Valid City of Chicago Food Service Sanitation Certificate required and must be posted.

Certificate must be: Current and valid; Posted conspicuously in public view; Held by person in charge during all operating hours; Renewed before expiration date.

PROPER EATING, TASTING, DRINKING, OR TOBACCO USE - Comments: OBSERVED MALE EMPLOYEE EATING FOOD IN FOOD PREP AREA INSTRUCTED TO EAT ONLY IN DESIGNATED AREA.(COS)

Hands are #1 vehicle for pathogen transfer. Bare hand contact with ready-to-eat foods causes majority of foodborne outbreaks.

Proper handwashing and no bare hand contact with ready-to-eat foods.

Wash hands for 20 seconds with soap and warm water; Use utensils, deli tissue, or gloves for ready-to-eat foods; Wash hands after restroom, handling raw foods, touching face/hair, and between tasks.

HANDS CLEAN & PROPERLY WASHED - Comments: OBSERVED 2- MALE & 2-FEMALE FOOD HANDLERS WEARING PLASTIC GLOVES AND USING SOILED WIPING CLOTHES TO WIPE CUTTING BOARDS AND WIPING THERE GLOVES ON THEM AND THEN HANDLING READY TO EAT FOODS SUCH AS (BREAD,BACON,EGGS) AS WELL AS WASHING THE PLASTIC GLOVES AT 3- COMPARTMENT SINK . INSTRUCTED MANAGER TO HAVE THEM TO REMOVE GLOVES,WASH HANDS AND PROVIDE CLEAN GLOVES AFTER EVERY POSSIBLE CONTAMINATION.(COS)(PRIORITY 7-38-010)(CITATION ISSUED)

Improper sanitization fails to kill pathogens, allowing contaminated equipment to spread illness throughout facility.

Sanitizing solutions and rinse water must meet specific requirements for effectiveness.

Chemical sanitizers: Chlorine 50-100 ppm, Quaternary ammonium 200-400 ppm, Iodine 12.5-25 ppm; Hot water: 171°F for 30 seconds or 180°F at dish surface; Test strips required; Proper contact time.

FOOD-CONTACT SURFACES: CLEANED & SANITIZED - Comments: OBSERVED MULTI-USE UTENSILS BEING SANITIZED AT 0.0PPM'S AT 3- COMPARTMENT SINK.OBSERVED FEMALE EMPLOYEE WASHING DISHES AT 3- COMPARTMENT SINK AND RINSING UNDER RUNNING WATER AND PLACING UTENSILS ON OVERHEAD DISH SHELF WITHOUT SANITIZING UTENSILS. INSTRUCTED TO SET UP SINK PROPERLY TO WASH ,RINSE AND SANITIZE UTENSILS.(COS)(PRIORITY 7-38-025)(CITATION ISSUED)

Dirty equipment harbors and spreads pathogens, causing cross-contamination and illness.

All food contact surfaces must be properly cleaned and sanitized.

Wash, rinse, sanitize after each use; Clean between different raw foods; Every 4 hours for continuous use; When contaminated; Proper procedures and chemicals.

PROPER COLD HOLDING TEMPERATURES - Comments: OBSERVED IMPROPER TEMPERATURES OF TCS READY TO EAT FOODS SUCH AS 2LBS. COOKED ONIONS -64.4F.5LBS. PRE-COOKED SAUSAGE-57.6F-70.3F.3LBS. COOKED RICE-49.5F INSIDE OF FRONT PREP COOLER AND WALK IN COOLER. PRODUCT WAS DISCARDED BY MANAGER .MUST HAVE COLD HOLDING FOODS AT 41.0F OR BELOW. APPX.10LBS. $37.(COS)(PRIORITY 7-38-005)(CITATION ISSUED)

Temperatures below 135°F allow bacteria to multiply, especially spore-formers that survive cooking.

Hot foods must be held at 135°F or above.

Maintain 135°F or above; Check temperatures regularly; Proper hot holding equipment; Cannot reheat in hot holding units.

FOOD PROPERLY LABELED; ORIGINAL CONTAINER - Comments: MUST LABEL SHAKERS AND SQUEEZE BOTTLES WHEN FOOD IS NOT IN ORIGINAL PACKAGE.

Missing allergen labeling can cause severe allergic reactions.

All food properly labeled with required information.

Common name; Ingredients; Allergen declarations; Date marking; Manufacturer info; Net quantity.

INSECTS, RODENTS, & ANIMALS NOT PRESENT - Comments: OBSERVED A GAP ALONG BOTTOM OF REAR DOOR MUST MAKE TIGHT FITTING.

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

CONTAMINATION PREVENTED DURING FOOD PREPARATION, STORAGE & DISPLAY - Comments: MUST ELEVATE BOXED & BUCKETS OF FOOD PRODUCTS OFF OF FLOOR IN WALK IN COOLER AND WALK IN FREEZER TO PREVENT CROSS CONTAMINATION.

Contamination during preparation is a leading cause of foodborne illness.

Prevent contamination during all food handling.

Minimize bare hand contact; Prevent cross-contamination; Use clean equipment; Proper employee hygiene.

WIPING CLOTHS: PROPERLY USED & STORED - Comments: OBSERVED WIPING CLOTHS STORED ON CUTTING BOARDS AND ON PREP TABLES MUST STORE IN A SANITIZING SOLUTION WHEN NOT IN USE.

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.

GLOVES USED PROPERLY - Comments: OBSERVED EMPLOYEES NOT USING GLOVES PROPERLY AFTER AFTER EVERY POSSIBLE CONTAMINATION.

Improper glove use spreads contamination worse than bare hands.

Single-use gloves must be used correctly.

Wash hands before donning; Change when contaminated; Change between tasks; Single use only; Not a substitute for handwashing.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: MUST REPAIR OR REPLACE WORN DOOR GASKETS ON WALK IN FREEZER.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: MUST CLEAN GREASE AND FOOD DEBRIS BUILD UP FROM FRYER CABINETS, GRILL TABLE. ICE BUILD UP FROM REACH IN FREEZER IN FRONT PREP AREA.

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: MUST REPAIR OR REPLACE LEAKY FAUCET AT 3- COMPARTMENT SINK.

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: MUST REPAIR OR REPLACE DAMAGED WALL TILES,MISSING CEILING TILE IN FRONT OF OFFICE.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: MUST ELEVATE,REMOVE AND ORGANIZE ARTICLES INSIDE OF MOPSINK AND ON FLOOR UNDER SAME.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: MUST CLEAN DEBRIS BUILD UP FROM FILTERS AT HOOD OF COOKING EQUIPMENT.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ALL FOOD EMPLOYEES HAVE FOOD HANDLER TRAINING - Comments: OBSERVED NO FOOD HANDLERS TRAINING FOR ALL EMPLOYEES MUST PROVIDE AND MAINTAIN.

Smoking contaminates hands and food with nicotine and tar residues.

Smoking prohibited in food establishments.

No smoking in any part of establishment; Designated areas away from food; Proper signage posted.

ALL FOOD EMPLOYEES HAVE FOOD HANDLER TRAINING - Comments: OBSERVED NO FOOD HANDLERS TRAINING FOR ALL EMPLOYEES MUST PROVIDE AND MAINTAIN.

Smoking contaminates hands and food with nicotine and tar residues.

Smoking prohibited in food establishments.

No smoking in any part of establishment; Designated areas away from food; Proper signage posted.