MAR & SUCHII Fails Health Inspection - Chicago Restaurant

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: OBSERVED NO SIGNED EMPLOYEES HEALTH POLICIES.MUST PROVIDE AND MAINTAIN.(PRIORITY FOUNDATION 7-38-010)(CITATION ISSUED)

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: OBSERVED NO HAND WASHING SINK IN REAR PREP AREAS.MUST INSTALL A HAND SINK WITH HOT & COLD RUNNING WATER,SOAP AND TOWELS.MUST PROVIDE AND MAINTAIN.(PRIORITY FOUNDATION 7-38-030(C)(CITATION ISSUED)

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

REQUIRED RECORDS AVAILABLE: SHELLSTOCK TAGS, PARASITE DESTRUCTION - Comments: OBSERVED NO 90-DAY SHELLFISH TAGS ON 40LBS. RAW OYSTERS STORED IN A PLASTIC BIN IN WALK IN COOLER.PRODUCT WAS DISCARDED BY MANAGER.MUST KEEP TAG WITH PRODUCT UNTIL LAST ONE IS SOLD OR USED.(PRIORITY FOUNDATION 7-38-005)(COS)(CITATION ISSUED)40LB.S $80.

Uncorrected violations continue posing health risks and often worsen over time.

Previous critical violations must be corrected.

All previous violations corrected within required timeframes; Critical violations corrected immediately; Documentation of corrections maintained.

FOOD-CONTACT SURFACES: CLEANED & SANITIZED - Comments: OBSERVED A MALE DISH WASHER NOT SANITIZING MULTI-USE UTENSILS AT 3- COMPARTMENT SINK. OBSERVED A BUCKET OF SOAPY WATER IN FAR RIGHT BASIN AND RINSING DISHES UNDER RUNNING WATER AND THEN PLACING DISHES ON OVERHEAD SHELF OF 3- COMPARTMENT SINK TO DRY. OBSERVED 0.0 P.P.M. FOR SANITIZING MULTI-USE UTENSIL. INSTRUCTED MANAGER ON HOW TO SET UP SINK DURING INSPECTION.(PRIORITY 7-38-025)(COS)(CITATION ISSUED)

Dirty equipment harbors and spreads pathogens, causing cross-contamination and illness.

All food contact surfaces must be properly cleaned and sanitized.

Wash, rinse, sanitize after each use; Clean between different raw foods; Every 4 hours for continuous use; When contaminated; Proper procedures and chemicals.

PROPER COLD HOLDING TEMPERATURES - Comments: OBSERVED IMPROPER TEMPERATURE OF TCS FOODS SUCH AS 4LBS. COOKED STEAK AT 57.6F INSIDE OF 3- DOOR PREP COOLER.PRODUCT WAS DISCARDED BY MANAGER.MUST HAVE COLD HOLDING FOODS AT 41.0F OR BELOW.(PRIORITY 7-38-005)(COS)(CITATION ISSUED)

Temperatures below 135°F allow bacteria to multiply, especially spore-formers that survive cooking.

Hot foods must be held at 135°F or above.

Maintain 135°F or above; Check temperatures regularly; Proper hot holding equipment; Cannot reheat in hot holding units.

COMPLIANCE WITH VARIANCE/SPECIALIZED PROCESS/HACCP - Comments: OBSERVED NO PH METER TO TEST ACIDITY FOR SUSHI RICE .MUST PROVIDE AND MAINTAIN.(PRIORITY FOUNDATION 7-38-005)(CITATION ISSUED)

Specialized processes without proper controls can create deadly toxins like botulism.

Special processes require approved HACCP plans or variances.

Written HACCP plan for: Vacuum packaging; Sous vide; Smoking for preservation; Curing; Using additives. Plan must be approved by CDPH.

COMPLIANCE WITH VARIANCE/SPECIALIZED PROCESS/HACCP - Comments: OBSERVED NO SUSHI LETTER THAT VERIFIES THAT VINEGAR IS USED AS A FOOD ADDITIVE.MUST PROVIDE AND MAINTIAN.

Specialized processes without proper controls can create deadly toxins like botulism.

Special processes require approved HACCP plans or variances.

Written HACCP plan for: Vacuum packaging; Sous vide; Smoking for preservation; Curing; Using additives. Plan must be approved by CDPH.

VARIANCE OBTAINED FOR SPECIALIZED PROCESSING METHODS - Comments: REFER TO VIOLATION #29.

Unapproved processes may lack critical safety controls.

Variance required before conducting specialized food processes.

Submit application to CDPH; Include HACCP plan; Await approval before starting; Maintain all required records.

PROPER COOLING METHODS USED; ADEQUATE EQUIPMENT FOR TEMPERATURE CONTROL - Comments: OBSERVED 3- DOOR PREP COOLER AT 60.8F WITH TCS READY TO EAT FOODS STORED INSIDE. A HELD FOR INSPECTION TAG HAS BEEN PLACED ON UNIT. ONCE REPAIRED EMAIL FOOD@CITYOFCHICAGO.ORG.MUST HAVE COLD HOLDING UNIT AT 41.0F OR BELOW.(PRIORITY 7-38-005)(COS)(CITATION ISSUED)

Dirty equipment harbors bacteria and attracts pests.

All equipment and utensils must be clean and properly maintained.

Equipment clean to sight and touch; Free of food debris and grease; Maintained in good repair; Stored properly when clean.

THERMOMETERS PROVIDED & ACCURATE - Comments: OBSERVED NO THERMOMETER FOR 3- DOOR PREP COOLER MUST PROVIDE AND MAINTAIN.

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

WIPING CLOTHS: PROPERLY USED & STORED - Comments: OBSERVED SEVERAL WIPING CLOTHS ON PREP TABLES AND CUTTING BOARDS THROUGHOUT MUST STORE IN A SANITIZING SOLUTION WHEN NOT IN USE.

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.

IN-USE UTENSILS: PROPERLY STORED - Comments: OBSERVED 2- ICE SCOOPS STORED ON TOPSIDE LID OF ICE MACHINE AND 1- INSIDE ON ICE IN BIN.MUST REMOVE AND STORE IN A CLEAN CONTAINER.

Improper storage contaminates utensils between uses.

In-use utensils must be properly stored between uses.

Store in food with handle out; On clean surface; In running water; In water at 135°F or above.

UTENSILS, EQUIPMENT & LINENS: PROPERLY STORED, DRIED, & HANDLED - Comments: MUST INVERT MULTI-USE UTENSILS ON DISH & PREP STORAGE SHELVES.

Clutter harbors pests and prevents proper cleaning.

Facility must be free of unnecessary items and litter.

Remove unnecessary equipment; No litter; Organized storage; No living quarters; Personal items in designated areas.

SINGLE-USE/SINGLE-SERVICE ARTICLES: PROPERLY STORED & USED - Comments: MUST STORE PLASTIC WEAR WITH HANDLES IN UPRIGHT POSITION.

Contaminated single-use items transfer pathogens to food and customers.

Single-use items must be protected from contamination.

Store in original packaging; Protect from contamination; Handle by non-contact surfaces; Cannot reuse.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: OBSERVED NO CHEMICAL TEST KIT TO CHECK SANITIZING SOLUTION PPM'S AT 3- COMPARTMENT SINK AND LOW TEMPERATURE DISH MACHINE. MUST PROVIDE AND MAINTAIN.(PRIORITY FOUNDATION 7-38-005)(CITATION ISSUED)

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: MUST CLEAN FOOD DEBRIS BUILD UP FROM FRYER CABINETS,PREP TABLES.

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: OBSERVED NO BACK FLOW DEVICE ON ICE MACHINE TO BE SEEN FOR SERVICING AND FLOOR BASIN MOP SINK.MUST INSTALL AND MAINTAIN.

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: MUST REPAIR OR REPLACE DAMAGED AND MISSING FLOOR TILES AT ENTRY WAY VESTIBULE, REAR STORAGE/PREP AREA UNDER SHELVING UNITS AND WASH MACHINE.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: OBSERVED TABLE TOP FRYER ON PREP TABLE. MUST STORE UNDER VENTILATION HOOD.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: OBSERVED DEBRIS BUILD UP ON FILTERS AND HOOD OF COOKING EQUIPMENT.MUST CLEAN AND MAINTAIN.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: OBSERVED DEBRIS BUILD UP ON FILTERS AND HOOD OF COOKING EQUIPMENT.MUST CLEAN AND MAINTAIN.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.