LEVINSONS INC Gets Conditional Pass on Health Inspection - Chicago Bakery

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: NO WRITTEN EMPLOYEE HEALTH POLICY ON SITE. MUST PROVIDE. PRIORITY FOUNDATION VIOLATION. NO CITATION ISSUED.

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: NO WRITTEN PROCEDURE OR REQUIRED DOCUMENTATION FOR A VOMITING OR DIARRHEA EVENT. MUST PROVIDE. PRIORITY FOUNDATION VIOLATION. NO CITATION ISSUED.

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: MUST INSTALL A HAND WASHING SINK WITH HOT AND COLD RUNNING WATER, SOAP AND PAPER TOWELS IN THE FRONT PREP AREA WHERE CAKES, PASTRIES AND COOKIES ARE HANDLED AND PACKAGED. PRIORITY FOUNDATION VIOLATION. NO CITATION ISSUED.

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

THERMOMETERS PROVIDED & ACCURATE - Comments: NO METAL STEM THERMOMETER ON SITE TO CHECK TCS FOODS UPON RECEIVING. MUST PROVIDE. PRIORITY FOUNDATION VIOLATION. NO CITATION ISSUED.

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

INSECTS, RODENTS, & ANIMALS NOT PRESENT - Comments: OBSERVED REAR EXIT SCREENED DOOR NOT INSECT PROOFED. NOTED TORN MESH SCREEN ON DOOR. MUST REPLACE/SEAL/REPAIR.

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED FOOD ENCRUSTED TABLETOP CAN OPENER. MUST CLEAN AFTER EACH USE.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: METAL SHELVING FOR SPICE STORAGE FOUND WITH FOOD DEBRIS AND DIRT. MUST CLEAN AND MAINTAIN.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: NOTED CONDENSER UNIT IN THE WALK-IN COOLER DRIPPING ONTO FLOOR OF COOLER. MUST PROVIDE A DRIP PAN, HOSE TO FLOOR DRAIN OR PREVENT FROM DRAINING.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: NOTED DISPOSABLE TINS FOR BAKING DIRTY WITH ENCRUSTED BAKED ON FOOD DEBRIS AND BEING REUSED. MUST NOT REUSE DISPOSABLE BAKE WARE AND ALL BAKE WARE MUST BE STORED CLEAN.

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: BACK FLOW PREVENTOR NOT LOCATED TO BE SERVICED AND MAINTAINED ON THE HOSE BIBS WITH HOSE ATTACHED AT THE REAR PLUMBING OF THE THREE COMPARTMENT SINK. MUST PROVIDE A BACK FLOW PREVENTOR.

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: 5-202.11 (B) NO GREASE TRAP LOCATED AT THE THREE COMPARTMENT SINK. MUST PROVIDE.

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: EMPLOYEES PERSONAL BELONGINGS SUCH AS PURSES, BABY CAR SEATS, CLOTHING NOTED IN VARIOUS FOOD PREPARATION AREAS. MUST PROVIDE STORAGE AREA FOR EMPLOYEES PERSONAL BELONGINGS, NOT IN FOOD OR FOOD PREP AREAS.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: MISSING LIGHT SHIELD END CAPS THROUGHOUT THE BAKING PREP AREA. MUST REPLACE/PROVIDE.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: MISSING LIGHT SHIELD END CAPS THROUGHOUT THE BAKING PREP AREA. MUST REPLACE/PROVIDE.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.