LAS CARNITAS URUAPAN Fails Health Inspection - Chicago Restaurant

FOOD-CONTACT SURFACES: CLEANED & SANITIZED - Comments: FOOD CONTACT SURFACES NOT CLEAN TO SIGHT AND TOUCH, EXCESSIVE DEBRIS NOTED ON SHELVES AND ENTIRE STORAGE RACKS IN WALK IN COOLER. PREMISES IS STORING LARGE QUANTITY OF COOKED, READY TO EAT CARNITAS DIRECTLY ON THESE SHELVING RACKS IN WALK IN COOLER THAT ARE UNABLE TO FULLY DISSASSEMBLE TO PROPERLY WASH, RINSE AND SANITIZE ALL SURFACES. INSTD TO USE PROPER FOOD GRADE MULTI USE EQUIPMENT AND ABLE TO PROPERLY WASH RINSE AND SANITIZE ALL SURFACES. PRIORITY FOUNDATION, CITATION ISSUED 7-38-005.

Dirty equipment harbors and spreads pathogens, causing cross-contamination and illness.

All food contact surfaces must be properly cleaned and sanitized.

Wash, rinse, sanitize after each use; Clean between different raw foods; Every 4 hours for continuous use; When contaminated; Proper procedures and chemicals.

PROPER COLD HOLDING TEMPERATURES - Comments: OBSERVED APPROX 150 LBS OF RAW PORK MEAT STORED IN 55 GALLON STORAGE BINS AT IMPROPER TEMPERATURES RANGING FROM 54F-67F IN THE FOOD PREP AREA. INSTRUCTED TO STORED TCS FOODS AT 41F OR BELOW. FOOD DISCARDED VAULED AT $500. PRIORTIY VIOLATION. CITATION ISSUED, 7-38-005.

Temperatures below 135°F allow bacteria to multiply, especially spore-formers that survive cooking.

Hot foods must be held at 135°F or above.

Maintain 135°F or above; Check temperatures regularly; Proper hot holding equipment; Cannot reheat in hot holding units.

PROPER DATE MARKING AND DISPOSITION - Comments: COOKED CARNITAS IN WALK IN COOLER NOT PROPERLY LABELED, DATED. REFRIGERATED, READY TO EAT TCS FOOD PREPARED AND HELD FOR MORE THAN 24 HOURS SHALL BE CLEARLY MARKED TO INDICATE THE DAY OR DATE BY WHICH FOOD SHALL BE SOLD OR DISCARDED FOR A MAXIMUM OF 7 DAYS. PRIORITY FOUNDATION VIOLATION 7-38-005. CITATION ISSUED.

Inadequate reheating fails to kill bacteria that grew during storage.

Foods must be reheated to 165°F within 2 hours.

Reheat to 165°F within 2 hours; Use proper equipment (not hot holding units); Discard if not reaching temperature in time.

THERMOMETERS PROVIDED & ACCURATE - Comments: NO THERMOMETER INSIDE OF TRUE REACH-IN COOLER IN WAIT STATION AREA. INSTRUCTED TO PROVIDE.

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

FOOD PROPERLY LABELED; ORIGINAL CONTAINER - Comments: OBSERVED FOOD STORAGE CONTAINERS NOT LABELED IN THE PREP AREA UNDER TABLES. INSTRUCTED TO LABEL ALL FOOD STORAGE CONTAINERS WITH THE COMMON NAME.

Missing allergen labeling can cause severe allergic reactions.

All food properly labeled with required information.

Common name; Ingredients; Allergen declarations; Date marking; Manufacturer info; Net quantity.

WIPING CLOTHS: PROPERLY USED & STORED - Comments: OBSERVED WET WIPING CLOTHS STORED ON COUNTERS THROUGHOUT THE FACILITY. INSTRUCTED TO KEEP ALL WIPE CLOTHS STORED IN PROPER SANITIZING SOLUTION WHEN NOT IN USE.

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.

SINGLE-USE/SINGLE-SERVICE ARTICLES: PROPERLY STORED & USED - Comments: OBSERVED SINGLE SERVICE WHITE CONTAINERS BEING REUSED IN THE FOOD PREP AREA. INSTRUCTED TO REMOVE AND NOT REUSE SINGLE SERVICE ARTICLES.

Contaminated single-use items transfer pathogens to food and customers.

Single-use items must be protected from contamination.

Store in original packaging; Protect from contamination; Handle by non-contact surfaces; Cannot reuse.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED CARDBOARD BEING USED AS SHELF LINER ON THE SHELVING IN THE FOOD PREP AREA.INSTRUCTED TO REMOVE THE CARDBOARD SO SURFACE IS SMOOTH, EVEN AND EASILY CLEANABLE.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: OBSERVED POTS IN THE PREP AREA AND AT THE COOKLINE TOO LARGE TO BE SUBMERGED IN THE 3-COMPARTMENT SINK. INSTRUCTED TO REMOVE LARGE DISHES THAT ARE TOO LARGE TO BE SUBMERGED IN THE 3-COMPARTMENT SINK FROM PREMISES OR PROVIDE A WRITTEN ALTERNATIVE WAREWASHING PROCEDURE THAT STATES HOW THE FACILITY WILL WASH, RINSE, AND SANITIZE LARGE DISHES.

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED CARDBOARD BEING USED AS FLOOR MATS AT THE COOKLINE. MUST REMOVE AND PROVIDE FLOOR COVERINGS THAT ARE A NON-ABSORBENT, NON-CORROSIVE, SMOOTH, EASILY CLEANABLE SURFACE.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED CARDBOARD BEING USED AS FLOOR MATS AT THE COOKLINE. MUST REMOVE AND PROVIDE FLOOR COVERINGS THAT ARE A NON-ABSORBENT, NON-CORROSIVE, SMOOTH, EASILY CLEANABLE SURFACE.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.