LA DULCE BAKERY INC Gets Conditional Pass on Health Inspection - Chicago Bakery

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: OBSERVED NO EMPLOYEE HEALTH POLICY ON SITE. MUST PROVIDE WRITTEN EMPLOYEE HEALTH POLICY FOR ALL EMPLOYEES. PRIORITY FOUNDATION VIOLATION 7-38-010. NO CITATION ISSUED.

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: OBSERVED NO VOMIT AND DIARRHEA CLEAN UP KIT/PROCEDURE ON SITE. MUST PROVIDE WRITTEN PROCEDURE FOR THE CLEAN UP OF VOMIT AND DIARRHEAL EVENTS, AND CORRESPONDING EQUIPMENT OUTLINE IN PROCEDURE. PRIORITY FOUNDATION VIOLATION 7-38-005. NO CITATION ISSUED.

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: OBSERVED NO SIGNAGE AT HANDSINK IN KITCHEN. MUST PROVIDE HANDWASHING SIGNAGE.

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

PROPER COLD HOLDING TEMPERATURES - Comments: OBSERVED IMPROPER TEMPERATURE OF TCS FOODS. FOUND 15 LBS OF EGGS SITTING ON COUNTER IN KITCHEN RANGING IN TEMPERATURES FROM 46.0F- 61.4F. INSTRUCTED ALL TCS FOODS MUST BE HELD AT 41F OR LESS AT ALL TIMES. OPERATOR VOLUNTARILY DISCARDED DENATURED FOODS DURING INSPECTION. ESTIMATED VALUE IS $20. PRIORITY FOUNDATION VIOLATION 7-38-005. NO CITATION ISSUED.

Temperatures below 135°F allow bacteria to multiply, especially spore-formers that survive cooking.

Hot foods must be held at 135°F or above.

Maintain 135°F or above; Check temperatures regularly; Proper hot holding equipment; Cannot reheat in hot holding units.

PROPER DATE MARKING AND DISPOSITION - Comments: OBSERVED IMPROPER DATES ON PREPPED TCS FOODS (PREPACKAGED DESERTS SUCH AS FLAN) INSIDE COOLERS. MUST PROPERLY LABEL ALL PREPPED TCS FOODS WITH DISCARD DATE NO MORE THAN 7 DAY FROM PREPARATION DATE. MUST CORRECT AND MAINTAIN SAME. PRIORITY FOUNDATION VIOLATION 7-38-005. NO CITATION ISSUED.

Inadequate reheating fails to kill bacteria that grew during storage.

Foods must be reheated to 165°F within 2 hours.

Reheat to 165°F within 2 hours; Use proper equipment (not hot holding units); Discard if not reaching temperature in time.

THERMOMETERS PROVIDED & ACCURATE - Comments: OBSERVED NO THERMOMETERS IN COOLERS IN FRONT SALES AREA COOLER. INSTRUCTED MUST PROVIDE THERMOMETERS IN A CONSPICUOUS SPOT IN ALL REFRIGERATION. MUST MAINTAIN SAME.

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

FOOD PROPERLY LABELED; ORIGINAL CONTAINER - Comments: OBSERVED ALLERGEN LABEL MISSING ON FOOD (DESERTS, ETC.) PACKAGED ON SITE, IN THE CUSTOMER SELF SERVICE DISPLAY COOLER ON SALES FLOOR. MUST LABEL THE NAME OF THE FOOD SOURCES OF ANY MAJOR FOOD ALLERGENS (I.E. MILK, EGGS, ETC.) PRIORITY FOUNDATION VIOLATION 7-38-005. NO CITATION ISSUED.

Missing allergen labeling can cause severe allergic reactions.

All food properly labeled with required information.

Common name; Ingredients; Allergen declarations; Date marking; Manufacturer info; Net quantity.

FOOD PROPERLY LABELED; ORIGINAL CONTAINER - Comments: OBSERVED BULK FOOD CONTAINERS (SUGAR, FLOUR, ETC.) WITHOUT REQUIRED LABELS. INSTRUCTED MUST LABEL ALL BULK FOOD CONTAINERS WITH COMMON NAME.

Missing allergen labeling can cause severe allergic reactions.

All food properly labeled with required information.

Common name; Ingredients; Allergen declarations; Date marking; Manufacturer info; Net quantity.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED RAW WOOD SURFACES AT FRONT COUNTER. INSTRUCTED MUST PAINT OR STAIN THESE POROUS SURFACES TO MAKE SMOOTH AND EASILY CLEANABLE. MUST MAINTAIN SAME.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: OBSERVED MIXING BOWLS (FOR CIP MIXER) TOO LARGE TO FULLY SUBMERGE IN EXISTING 3 COMPARTMENT SINKS TO PROPERLY WASH, RINSE AND SANITIZE. INSTRUCTED MUST REPLACE EXISTING SINKS WITH BASINS LARGE ENOUGH TO ACCOMMODATE ALL POTS/UTENSILS; OR PROVIDE AN APPROVED METHOD (AND DEMONSTRATE) TO PROPERLY WASH, RINSE AND SANITIZE MIXING BOWLS AND CIP MIXER.

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: OBSERVED MIXING BOWLS (FOR CIP MIXER) TOO LARGE TO FULLY SUBMERGE IN EXISTING 3 COMPARTMENT SINKS TO PROPERLY WASH, RINSE AND SANITIZE. INSTRUCTED MUST REPLACE EXISTING SINKS WITH BASINS LARGE ENOUGH TO ACCOMMODATE ALL POTS/UTENSILS; OR PROVIDE AN APPROVED METHOD (AND DEMONSTRATE) TO PROPERLY WASH, RINSE AND SANITIZE MIXING BOWLS AND CIP MIXER.

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.