HUB 51 Fails Health Inspection - Chicago Restaurant

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: OBSERVED NO WRITTEN EMPLOYEE HEALTH POLICY ON THE PREMISES. MANAGEMENT INSTRUCTED TO PROVIDE A SIGNED EMPLOYEE HEALTH POLICY FOR EACH EMPLOYEE. PRIORITY FOUNDATION 7-38-010,NO CITATION ISSUED. -

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: OBSERVED NO CLEAN UP PROCEDURE ON THE PREMISES FOR VOMIT AND DIARRHEAL EVENTS. MANAGEMENT INSTRUCTED TO PROVIDE A CLEAN UP PROCEDURE AND SUPPLIES. PRIORITY FOUNDATION 7-38-005, NO CITATION ISSUED. -

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: AT TIME OF INSPECTION, THE REAR PREP/DISHWASHING AREA HANDWASHING SINK WAS BLOCKED A LARGE KITCHEN STORAGE SHELF WITH KITCHEN MULTI-USE SHEET PANS AND CONTAINERS AND SOME KITCHEN MULTI-USE CONTAINERS WERE ALSO,HANGING OUT FROM SHELVING OBSTRUCTING SAID HANDWASHING SINK. INSTRUCTED TO MOVE SAID SHELVING UNIT AND MAINTAIN HANDWASHING SINK (ACCESSIBLE) FOR HANDWASHING AND MAINTAIN AT ALL TIMES. PRIORITY FOUNDATION VIOLATION 7-38-030(C),CITATION ISSUED. - COS.

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

FOOD-CONTACT SURFACES: CLEANED & SANITIZED - Comments: OBSERVED BLACK SLIMY SUBSTANCES ON INTERIOR WATER COMPONENTS OF THE ICE MACHINE,DRIPPING INTO ICE "ICE IS USED FOR HUMAN CONSUMPTION". MANAGEMENT WAS INSTRUCTED TO TURN OFF MACHINE, REMOVE ICE AND HAVE INTERIOR OF ICE MACHINE CLEANED AND SANITIZED AND MAINTAIN. PRIORITY FOUNDATION VIOLATION 7-38-005,CITATION ISSUED.

Dirty equipment harbors and spreads pathogens, causing cross-contamination and illness.

All food contact surfaces must be properly cleaned and sanitized.

Wash, rinse, sanitize after each use; Clean between different raw foods; Every 4 hours for continuous use; When contaminated; Proper procedures and chemicals.

COMPLIANCE WITH VARIANCE/SPECIALIZED PROCESS/HACCP - Comments: OBSERVED OUTDATED SUSHI RICE LAB RESULTS FROM (3.30.12).INSTRUCTED TO PROVIDE UPDATED LAB LETTER FOR SUSHI RICE AND MAINTAIN THE PH METER ON SITE AT ALL TIMES. PRIORITY FOUNDATION VIOLATION 7-38-005,NO CITATION ISSUED.

Specialized processes without proper controls can create deadly toxins like botulism.

Special processes require approved HACCP plans or variances.

Written HACCP plan for: Vacuum packaging; Sous vide; Smoking for preservation; Curing; Using additives. Plan must be approved by CDPH.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED BLUE COLORED CODED CUTTING BOARD WITH DEEP CUTS/STAINS AND LONG CUTTING BOARDS AT PREP LINE COOLERS.INSTRUCTED TO REPLACE AND TO MAINTAIN.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED TORN GASKET AT BOTTOM OF DOOR FOR WALK-IN-COOLER.INSTRUCTED TO REPLACE TORN GASKET AND MAINTAIN.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: INSTRUCTED TO DETAIL CLEAN AND MAINTAIN INTERIORS OF REFRIGERATION UNITS,EXTERIOR OF DISHMACHINE,SIDES OF HOT COOKING EQUIPMENTS (STEAMER,OVEN) WITH BUILD-UP OF SPLASHED FOOD DEBRIS,BAR GUNS AND HOUSINGS ATTACHED,FOOD PREP DRY GOODS STORAGE SHELVINGS,MANUAL CAN OPENER AT REAR FOOD PREP TABLE WITH FOOD DEBRIS.

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: BACKFLOW PREVENTER NOT LOCATED AT ICE MACHINE IN FOOD PREP AREA.INSTRUCTED TO INSTALL SO THAT IT CAN BE LOCATED TO BE SERVICED AND MAINTAINED. -

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: INSTRUCTED TO REPLACE DAMAGED CEILING TILES IN FOOD PREP AREA WHERE NOTED TO MANAGER AND MAINTAIN TO SMOOTH,EASILY CLEANABLE SURFACES.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: INSTRUCTED TO DETAIL CLEAN AND ORGANIZE CLUTTERED CORNER AT REAR UNDERNEATH OVEN FOOD PREP/DISHWASHING AREA AND REMOVE UNNECESSARY ARTICLES DUE TO POTENTIAL PEST HARBORAGE AND PROPERLY STORE AND ELEVATE AND MAINTAIN AT LEAST 6" INCHES OFF FLOOR FOR BROOMS AND CLEANING FLOOR EQUIPMENTS.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: INSTRUCTED TO DETAIL CLEAN INTERIOR HOOD ABOVE THE DISHMACHINE TO REMOVE ACCUMULATIONS OF DUSTS AND TO MAINTAIN.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: INSTRUCTED TO DETAIL CLEAN INTERIOR HOOD ABOVE THE DISHMACHINE TO REMOVE ACCUMULATIONS OF DUSTS AND TO MAINTAIN.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.