HERNANDEZ ENTERPRISES INC Fails Health Inspection - Chicago Bakery

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: FOUND NO EMPLOYEE HEALTH POLICY/TRAINING ON SITE. INSTRUCTED FACILITY TO ESTABLISH AN APPROPRIATE EMPLOYEE HEALTH POLICY/TRAINING SYSTEM AND MAINTAIN WITH VERIFIABLE DOCUMENTS ON SITE. PRIORITY FOUNDATION VIOLATION 7-38-012. NO CITATION ISSUED.

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: FOUND NO PROCEDURE/PLAN FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS. INSTRUCTED FACILITY TO DEVELOP AND MAINTAIN A PROCEDURE/PLAN AND TO MAINTAIN ANY APPROPRIATE SUPPLIES ON SITE. PRIORITY FOUNDATION VIOLATION 7-38-005. NO CITATION ISSUED

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: OBSERVED ADDITIONAL HANDWASHING SINK NEEDED IN FRONT PREP AREA WITH HOT AND COLD RUNNING WATER, SOAP AND PAPER TOWELS. CONVENIENT AND ACCESSIBLE FOR LARGE BAKERY PREP TABLE WEST OF WALK IN COOLER. INSTALL AND MAINTAIN. PRIORITY FOUNDATION VIOLATION. NO CITATION ISSUED

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

PROPER DATE MARKING AND DISPOSITION - Comments: OBSERVED NO DATE MARKING SYSTEM IN PLACE. READY TO EAT AND OR TIME TEMPERATURE CONTROLLED FOODS PREPARED AND HELD IN A RETAIL FOOD ESTABLISHMENT FOR OVER 24 HOURS MUST HAVE A CLEARLY MARKED LABELING SYSTEM IN PLACE TO INDICATE THE DATE OR DAY BY WHICH THE FOOD SHALL BE CONSUMED ON PREMISES, SOLD, OR DISCARDED WHEN HELD AT A TEMPERATURE OF 41F OR LESS FOR A MAXIMUM OF 7 DAYS WITH THE DATE OF PREPARTION COUNTING AS DAY. PRIORITY FOUNDATION VIOLATION 7-38-005 NO CITATION ISSUED

Inadequate reheating fails to kill bacteria that grew during storage.

Foods must be reheated to 165°F within 2 hours.

Reheat to 165°F within 2 hours; Use proper equipment (not hot holding units); Discard if not reaching temperature in time.

INSECTS, RODENTS, & ANIMALS NOT PRESENT - Comments: OBSERVED 2 LIVE COCKROACHES PRESENT. MUST CONTACT PEST CONTROL AND ELIMINATE ACTIVITY. PRIORITY FOUNDATION VIOLATION 7-38-020 (A)

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED LARGE WOODEN PREP TABLE WITH RAW WOOD LOWER SHELF THAT NEEDS TO BE PAINTED OF SEALED. OBSERVED TOP OF LARGE WOODEN PREP TABLE WITH GAPS IN BETWEEN WOOD WHERE FLOUR AND FOOD DEBRIS IS GATHERING. TABLE NEEDS TO BE SEALED SO THAT NO FOOD IS ABLE TO GATHER IN GAPS OF TABLE. TABLE NEEDS TO BE RESEALED SO THAT IT IS SMOOTH AND EASILY CLEANABLE. MAINTAIN PREP TABLE OR REPLACE. OBSERVED 2 PLASTIC SLIDING DOORS FOR FRONT WINDOW DISPLAY CASE WITH CRACKED AND BROKEN PLASTIC. MUST REPLACE DOORS ON FRONT WINDOW DISPLAY CASE.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: OBSERVED THE FOLLOWING NON FOOD CONTACT SURFACES NEED TO BE CLEANED IN DETAIL. ALL SHELVING IN WALK IN COOLER. ALL SHELVING CONTAINING DRY STORAGE. CLEAN IN DETAIL AND MAINTAIN.

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: OBSERVED THE FOLLOWING NON FOOD CONTACT SURFACES NEED TO BE CLEANED IN DETAIL. ALL SHELVING IN WALK IN COOLER. ALL SHELVING CONTAINING DRY STORAGE. CLEAN IN DETAIL AND MAINTAIN.

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.