FOREST VIEW BAKERY Gets Conditional Pass on Health Inspection - Chicago Bakery

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: OBSERVED NO EMPLOYEES HEALTH POLICY.MUST PROVIDE AND MAINTAIN.(PRIORITY FOUNDATION-7-38.010-NO CITATION ISSUED)

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: OBSERVED NO CLEAN-UP OF VOMITING AND DIARRHEA PROCEDURE AND CLEAN-UP KIT ON PREMISES DURING INSPECTION. INSTRUCTED TO HAVE SAID PROCEDURE ALONG WITH REQUIRED EQUIPMENT FOR CLEAN-UP. PRIORITY FOUNDATION VIOLATION. NO CITATION ISSUED. 7-38-005

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

PROPER DATE MARKING AND DISPOSITION - Comments: OBSERVED READY TO EAT, TIME FOR TEMPERATURE SAFETY FOR CONTROL FOODS NOT PROPERLY DATED IN COOLERS. INSTRUCTED TO PROVIDE PROPER DATE MARKING WITH DISPOSITION DATE FOR RTE FOODS PREPARED ON SITE AND HELD OVER 24 HOURS IN COLD HOLDING UNIT. PRIORITY FOUNDATION VIOLATION. NO CITATION ISSUED. 7-38-005

Inadequate reheating fails to kill bacteria that grew during storage.

Foods must be reheated to 165°F within 2 hours.

Reheat to 165°F within 2 hours; Use proper equipment (not hot holding units); Discard if not reaching temperature in time.

THERMOMETERS PROVIDED & ACCURATE - Comments: NOTED NO THERMOMETERS INSIDE REFRIGERATION UNIT CONSPICUOUSLY POSTED TO MONITOR THE AMBIENT TEMPERATURE OF EQUIPMENT. INSTRUCTED TO EQUIP ALL REFRIGERATION UNITS WITH ACCURATE AND WORKING THERMOMETERS

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: MUST REPAIR OR REPLACE BROKEN AND DAMAGED DOOR GASKETS ON ALL COOLING-FREEZING UNITS

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: OBSERVED BAKING EQUIPMENT(MIXERS) TO BE BIGGER THAN 3 COMPARTMENT SINK AND CANT BE SUBMERGED IN WASH WATER IN SINK.MUST PROVIDE CLEANING PROCEDURE FOR EACH SEPARATE PIECE OF FOOD-CONTACT EQUIPMENT WITH DESCRIPTION HOW TO BE CLEANED IN PLACE AND/OR .MUST SUBMIT THE PROCEDURES TO CDPH AT FOOD@CITYOFCHICAGO.ORG FOR APPROVAL PRIOR TO RE-INSPECTION. PRIORITY FOUNDATION VIOLATION#: 7-38-025.NO CITATION ISSUED.

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

TOILET FACILITIES: PROPERLY CONSTRUCTED, SUPPLIED, & CLEANED - Comments: MUST CLEAN ALL TOILETS FIXTURES IN EMPLOYEE BATHROOMS UPSTAIRS AND DOWNSTAIRS.VIOLATION PARTIALLY CORRECTED.UPSTAIRS BATHROOM CLEANED BUT DOWN STAIRS NOT

Inadequate facilities lead to poor hygiene and contamination.

Toilet rooms must be properly equipped and maintained.

Self-closing doors; Toilet paper; Covered waste receptacles; Handwashing supplies; Cleaned regularly; Proper ventilation.

This violation was corrected during the inspection.

TOILET FACILITIES: PROPERLY CONSTRUCTED, SUPPLIED, & CLEANED - Comments: MUST PROVIDE TOILET ROOM RECEPTACLE WITH COVER FOR SANITARY NAPKINS IN BOTH UNISEX EMPLOYEE BATHROOMS

Inadequate facilities lead to poor hygiene and contamination.

Toilet rooms must be properly equipped and maintained.

Self-closing doors; Toilet paper; Covered waste receptacles; Handwashing supplies; Cleaned regularly; Proper ventilation.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: MUST REPAIR OR REPLACE ALL NON WORKING LIGHT BULBS IN FOOD PREP AREA

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ALL FOOD EMPLOYEES HAVE FOOD HANDLER TRAINING - Comments: OBSERVED NO FOOD HANDLER'S TRAINING CERTIFICATION FROM EMPLOYEE. INSTRUCTED THAT ALL EMPLOYEE'S MUST COMPLY WITH FOOD HANDLER'S TRAINING IN ACCORDANCE WITH THE FOOD HANDLING REGULATION ENFORCEMENT ACT

Smoking contaminates hands and food with nicotine and tar residues.

Smoking prohibited in food establishments.

No smoking in any part of establishment; Designated areas away from food; Proper signage posted.

ALL FOOD EMPLOYEES HAVE FOOD HANDLER TRAINING - Comments: OBSERVED NO FOOD HANDLER'S TRAINING CERTIFICATION FROM EMPLOYEE. INSTRUCTED THAT ALL EMPLOYEE'S MUST COMPLY WITH FOOD HANDLER'S TRAINING IN ACCORDANCE WITH THE FOOD HANDLING REGULATION ENFORCEMENT ACT

Smoking contaminates hands and food with nicotine and tar residues.

Smoking prohibited in food establishments.

No smoking in any part of establishment; Designated areas away from food; Proper signage posted.