FOREST VIEW BAKERY Fails Health Inspection - Chicago Bakery

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: OBSERVED NO EMPLOYEES HEALTH POLICY.MUST PROVIDE AND MAINTAIN.(PRIORITY FOUNDATION-7-38.010-NO CITATION ISSUED)

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: OBSERVED NO CLEAN-UP OF VOMITING AND DIARRHEA PROCEDURE AND CLEAN-UP KIT ON PREMISES DURING INSPECTION. INSTRUCTED TO HAVE SAID PROCEDURE ALONG WITH REQUIRED EQUIPMENT FOR CLEAN-UP. PRIORITY FOUNDATION VIOLATION. NO CITATION ISSUED. 7-38-005

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

NO BARE HAND CONTACT WITH RTE FOOD OR A PRE-APPROVED ALTERNATIVE PROCEDURE PROPERLY ALLOWED - Comments: OBSERVED THAT EMPLOYEE USES BARE HAND WHILE TOUCHING AND PACKING READY TO EAT FOOD.7-38-010 PRIORITY VIOLATION 7-38.010 CITATION ISSUED

Contaminated water spreads waterborne diseases. Insufficient hot water prevents proper sanitization.

Potable water supply must be adequate, protected, and properly heated.

Water from approved public system; Sufficient pressure for all operations; Hot water minimum 120°F at fixtures, 180°F for high-temp dishwashers; Backflow prevention installed; No cross-connections.

FOOD-CONTACT SURFACES: CLEANED & SANITIZED - Comments: BAKING EQUIPMENT OBSERVED TO BE COVERED WITH FOOD DEBRIS AND HAVE NOT BEEN CLEANED EVERY 24 HOURS

Dirty equipment harbors and spreads pathogens, causing cross-contamination and illness.

All food contact surfaces must be properly cleaned and sanitized.

Wash, rinse, sanitize after each use; Clean between different raw foods; Every 4 hours for continuous use; When contaminated; Proper procedures and chemicals.

PROPER DATE MARKING AND DISPOSITION - Comments: OBSERVED READY TO EAT, TIME FOR TEMPERATURE SAFETY FOR CONTROL FOODS NOT PROPERLY DATED IN COOLERS. INSTRUCTED TO PROVIDE PROPER DATE MARKING WITH DISPOSITION DATE FOR RTE FOODS PREPARED ON SITE AND HELD OVER 24 HOURS IN COLD HOLDING UNIT. PRIORITY FOUNDATION VIOLATION. NO CITATION ISSUED. 7-38-005

Inadequate reheating fails to kill bacteria that grew during storage.

Foods must be reheated to 165°F within 2 hours.

Reheat to 165°F within 2 hours; Use proper equipment (not hot holding units); Discard if not reaching temperature in time.

THERMOMETERS PROVIDED & ACCURATE - Comments: OBSERVED NO PROBE THERMOMETER FOR TAKING FOOD TEMPERATURES.MUST PROVIDE.(PRIORITY FOUNDATION-NO CITATION ISSUED) -7-38-005

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

THERMOMETERS PROVIDED & ACCURATE - Comments: NOTED NO THERMOMETERS INSIDE REFRIGERATION UNIT CONSPICUOUSLY POSTED TO MONITOR THE AMBIENT TEMPERATURE OF EQUIPMENT. INSTRUCTED TO EQUIP ALL REFRIGERATION UNITS WITH ACCURATE AND WORKING THERMOMETERS

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

PERSONAL CLEANLINESS - Comments: ALL EMPLOYEES OBSERVED NOT HAVE THERE HAIR PROPERLY RESTRAINED WHILE WORKING WITH EXPOSED FOOD

Poor personal hygiene transfers contaminants to food.

Food handlers must maintain personal cleanliness.

Clean outer clothing; Hair restraints; Short, clean fingernails; No jewelry except plain ring; Clean hands and arms.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED USE OF UNPROTECTED WOOD PALLETS IN REACH IN COOLER,MUST REMOVE AND USE PROPER APPROVED FOOD STORAGE AND SHELVES

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: MUST REPAIR OR REPLACE BROKEN AND DAMAGED DOOR GASKETS ON ALL COOLING-FREEZING UNITS

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: MUST CLEAN AND MAINTAIN CLEAN INTERIOR OF ALL COOLING UNITS

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: OBSERVED NO CHEMICAL TEST KIT FOR CHECKING SANITIZING SOLUTION P.P.M.'S AT 3- COMP SINK.MUST PROVIDE AND MAINTAIN.(PRIORITY FOUNDATION 7-38-005) -CITATION ISSUED

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: OBSERVED BAKING EQUIPMENT(MIXERS) TO BE BIGGER THAN 3 COMPARTMENT SINK AND CANT BE SUBMERGED IN WASH WATER IN SINK.MUST PROVIDE CLEANING PROCEDURE FOR EACH SEPARATE PIECE OF FOOD-CONTACT EQUIPMENT WITH DESCRIPTION HOW TO BE CLEANED IN PLACE AND/OR .MUST SUBMIT THE PROCEDURES TO CDPH AT FOOD@CITYOFCHICAGO.ORG FOR APPROVAL PRIOR TO RE-INSPECTION. PRIORITY FOUNDATION VIOLATION#: 7-38-025.NO CITATION ISSUED.

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: MUST CLEAN EXTERIOR OF BAKING AND FOOD STORAGE COOLING UNITS

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

TOILET FACILITIES: PROPERLY CONSTRUCTED, SUPPLIED, & CLEANED - Comments: MUST CLEAN ALL TOILETS FIXTURES IN EMPLOYEE BATHROOMS UPSTAIRS AND DOWNSTAIRS

Inadequate facilities lead to poor hygiene and contamination.

Toilet rooms must be properly equipped and maintained.

Self-closing doors; Toilet paper; Covered waste receptacles; Handwashing supplies; Cleaned regularly; Proper ventilation.

TOILET FACILITIES: PROPERLY CONSTRUCTED, SUPPLIED, & CLEANED - Comments: NOTED THE BATHROOM DOOR AT THE REAR FOOD PREP AREA NOT SELF CLOSING. INSTRUCTED TO PROVIDE A SELF CLOSING DEVICE AT THE DOOR AND MAINTAIN

Inadequate facilities lead to poor hygiene and contamination.

Toilet rooms must be properly equipped and maintained.

Self-closing doors; Toilet paper; Covered waste receptacles; Handwashing supplies; Cleaned regularly; Proper ventilation.

TOILET FACILITIES: PROPERLY CONSTRUCTED, SUPPLIED, & CLEANED - Comments: MUST PROVIDE TOILET ROOM RECEPTACLE WITH COVER FOR SANITARY NAPKINS IN BOTH UNISEX EMPLOYEE BATHROOMS

Inadequate facilities lead to poor hygiene and contamination.

Toilet rooms must be properly equipped and maintained.

Self-closing doors; Toilet paper; Covered waste receptacles; Handwashing supplies; Cleaned regularly; Proper ventilation.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: NOTED CLUTTER OF EQUIPMENT AND OTHER UNUSED ITEMS ON FLOORS IN STORAGE ROOMS.MUST ELEVATE ALL ITEMS TO ALLOW CLEANING AND REMOVE ALL UNNECESSARY ITEMS.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: MUST CLEAN DEBRIS BUILD UP FROM FLOOR ALONG WALL BASES IN PREP AND DISH WASHING AREAS AND REAR OPEN STORAGE AREA

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: MUST REPAIR OR REPLACE ALL NON WORKING LIGHT BULBS IN FOOD PREP AREA

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ALL FOOD EMPLOYEES HAVE FOOD HANDLER TRAINING - Comments: OBSERVED NO FOOD HANDLER'S TRAINING CERTIFICATION FROM EMPLOYEE. INSTRUCTED THAT ALL EMPLOYEE'S MUST COMPLY WITH FOOD HANDLER'S TRAINING IN ACCORDANCE WITH THE FOOD HANDLING REGULATION ENFORCEMENT ACT

Smoking contaminates hands and food with nicotine and tar residues.

Smoking prohibited in food establishments.

No smoking in any part of establishment; Designated areas away from food; Proper signage posted.

ALL FOOD EMPLOYEES HAVE FOOD HANDLER TRAINING - Comments: OBSERVED NO FOOD HANDLER'S TRAINING CERTIFICATION FROM EMPLOYEE. INSTRUCTED THAT ALL EMPLOYEE'S MUST COMPLY WITH FOOD HANDLER'S TRAINING IN ACCORDANCE WITH THE FOOD HANDLING REGULATION ENFORCEMENT ACT

Smoking contaminates hands and food with nicotine and tar residues.

Smoking prohibited in food establishments.

No smoking in any part of establishment; Designated areas away from food; Proper signage posted.