FIREHOUSE OF DAN RYAN, INC. Fails Health Inspection - Chicago Restaurant

ADEQUATE NUMBER, CONVENIENT, ACCESSIBLE, DESIGNED, AND MAINTAINED - Comments: FRONT EXPOSED SINK NOT MAINTAINED, SINK NOT PROPERLY DRAINING. INSTRUCTED MANAGER TO REPAIR EXPOSED SINK FOR PROPER HAND WASHING. CRITICAL VIOLATION 7-38-030

Inadequate facilities lead to poor hygiene practices and potential fecal contamination.

Sufficient, properly maintained toilet facilities required.

Adequate number for staff; Convenient location; Self-closing doors; Toilet paper; Covered waste receptacles; Maintained clean; Proper ventilation.

FOOD PROTECTED DURING STORAGE, PREPARATION, DISPLAY, SERVICE AND TRANSPORTATION - Comments: OBSERVED BLACK AND RED MOLD LIKE SUBSTANCE ON INTERIOR PANEL OF ICE MACHINE. INSTRUCTED MANAGER TO CLEAN AND SANITIZE ICE MACHINE. SERIOUS VIOLATION 7-38-005A

Dirty equipment harbors and spreads pathogens, causing cross-contamination and illness.

All food contact surfaces must be properly cleaned and sanitized.

Wash, rinse, sanitize after each use; Clean between different raw foods; Every 4 hours for continuous use; When contaminated; Proper procedures and chemicals.

DISH MACHINES: PROVIDED WITH ACCURATE THERMOMETERS, CHEMICAL TEST KITS AND SUITABLE GAUGE COCK - Comments: OBSERVED NO CHEMICAL SANITIZER TEST KIT AVAILABLE DURING INSPECTION. INSTRUCTED MANAGER TO PROVIDE TEST KIT FOR PROPER SANITIZER CONCENTRATION. SERIOUS VIOLATION 7-38-030

Temperatures below 135°F allow bacteria to multiply, especially spore-formers that survive cooking.

Hot foods must be held at 135°F or above.

Maintain 135°F or above; Check temperatures regularly; Proper hot holding equipment; Cannot reheat in hot holding units.

PREVIOUS MINOR VIOLATION(S) CORRECTED 7-42-090 - Comments: PREVIOUS MINOR VIOLATIONS NOT CORRECTEED FROM REPORT #2081268 ON 8-29-17:35-REPLACE ALL MISSING BASEBOARDS ALONG WALLS IN REAR PREP AREA. 38-REPAIR LEAK UNDER BASIN OF REAR EXPOSED SINK. 40-PROVIDE THERMOMETERS IN REACH-IN AND PREP COOLERS IN FRONT PREP AREA. 41-PROPERLY ORGANIZE AND ELEVATE ALL STOCK OFF FLOOR IN WALK-IN COOLER AND WALK-IN FREEZER. SERIOUS VIOLATION 7-42-090

Specialized processes without proper controls can create deadly toxins like botulism.

Special processes require approved HACCP plans or variances.

Written HACCP plan for: Vacuum packaging; Sous vide; Smoking for preservation; Curing; Using additives. Plan must be approved by CDPH.

This violation was corrected during the inspection.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: SEAL LOOSE GASKET ON UPRIGHT COOLER IN FRONT PREP AREA. REPLACE MISSING DOORS ON FRYER CABINETS. INSTALL SPLASH GUARD BETWEEN EXPOSED SINK AND PREP SINK IN FRONT PREP AREA. DEFROST INTERIOR OF FRONT DISPLAY COOLER.

Unapproved processes may lack critical safety controls.

Variance required before conducting specialized food processes.

Submit application to CDPH; Include HACCP plan; Await approval before starting; Maintain all required records.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: CLEAN INTERIOR AND EXTERIOR OF ALL COOLERS, FREEZERS, PREP TABLES, SINKS, COOKING EQUIPMENT.

Dirty equipment harbors bacteria and attracts pests.

All equipment and utensils must be clean and properly maintained.

Equipment clean to sight and touch; Free of food debris and grease; Maintained in good repair; Stored properly when clean.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: CLEAN FLOORS UNDER ALL EQUIPMEMNT, ALONG WALLS AND IN ALL CORNERS IN PREP AND STORAGE AREAS.

Damaged floors harbor bacteria and create safety hazards.

Floors must be smooth, cleanable, and maintained.

Smooth, non-porous in food areas; Properly sloped to drains; Coving at wall junctures; Kept clean; Good repair.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: CLEAN ALL CEILING VENTS IN PREP AREAS.

Damaged surfaces cannot be properly cleaned and may harbor pests.

Walls and ceilings must be smooth, cleanable, and in good repair.

Smooth, washable surfaces in food areas; Light colored; No holes or cracks; Clean and maintained.

LIGHTING: REQUIRED MINIMUM FOOT-CANDLES OF LIGHT PROVIDED, FIXTURES SHIELDED - Comments: PROVIDE ADEQUATE LIGHTING AND REPLACE MISSING LIGHT SHIELD IN WALK-IN COOLER.

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

VENTILATION: ROOMS AND EQUIPMENT VENTED AS REQUIRED: PLUMBING: INSTALLED AND MAINTAINED - Comments: REPAIR LEAKING DRAINPIPE UNDER REAR EXPOSED SINK.

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

PREMISES MAINTAINED FREE OF LITTER, UNNECESSARY ARTICLES, CLEANING EQUIPMENT PROPERLY STORED - Comments: ELEVATE ALL STOCK OFF FLOOR IN WALK-IN COOLER, WALK-IN FREEZER, AND PREP AREA.

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.

PREMISES MAINTAINED FREE OF LITTER, UNNECESSARY ARTICLES, CLEANING EQUIPMENT PROPERLY STORED - Comments: ELEVATE ALL STOCK OFF FLOOR IN WALK-IN COOLER, WALK-IN FREEZER, AND PREP AREA.

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.