EL REY DEL MAIZ Fails Health Inspection - Chicago Bakery

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: NO EMPLOYEE HEALTH POLICY ON SITE. MUST PROVIDE PRIORITY FOUNDATION VIOLATION#: 7-38-012(a) NO CITATION ISSUED.

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

CONTAMINATION PREVENTED DURING FOOD PREPARATION, STORAGE & DISPLAY - Comments: MUST PROVIDE BARRIER TO ENTRYWAY FROM CONSUMER SERVICE AREA INTO THE FRONT PREP AREA. BARRIER PROVIDED MUST NOT ALLOW MORE THAN A 36" OPENING IN THE ENTRYWAY INTO THE FOOD PREP AREA. NO CITATION ISSUED PRIORITY VIOLATION#: 7-38-005

Contamination during preparation is a leading cause of foodborne illness.

Prevent contamination during all food handling.

Minimize bare hand contact; Prevent cross-contamination; Use clean equipment; Proper employee hygiene.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: MUST PROVIDE SINK STOPPERS FOR THREE COMPARTMENT SINK.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: MUST PROVIDE A WRITTEN DETAILED CLEANING PROCEDURE FOR ALL FOOD-CONTACT EQUIPMENT THAT IS TOO LARGE TO BE SUBMERGED IN THE THREE COMPARTMENT SINK; INCLUDING THE SEMI-COOKING TUB, SOAKING/CLEANING OF CORN TUB, LARGE GRINDER, AND ROLLING TRANSPORT CART. MUST SUBMIT PROCEDURE TO CDPH AT FOOD@CITYOFCHICAGO.ORG FOR APPROVAL. PRIORITY FOUNDATION VIOLATION#: 7-38-025 NO CITATION ISSUED

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: MUST CLEAN INTERIOR OF FRONT PREP CABINET/COUNTER TABLE.

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

HOT & COLD WATER AVAILABLE; ADEQUATE PRESSURE - Comments: OBSERVED A 40GAL HOT WATER TANK ON SITE FOR ENTIRE FOOD ESTABLISHMENT. MUST PROVIDE SUFFICIENT HOT WATER DISTRIBUTION SYSTEM TO MEET THE PEAK HOT WATER DEMANDS THROUGHOUT THE FOOD ESTABLISHMENT. PRIORITY FOUNDATION VIOLATION#: 7-38-030(C) NO CITATION ISSUED

Without proper water temperatures, cannot sanitize or clean properly.

Adequate hot and cold running water required.

Hot water 120°F minimum at fixtures; Cold water available; Sufficient pressure; From approved source.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: MUST PROVIDE GREASE TRAP FOR THREE COMPARTMENT SINK.

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

SEWAGE & WASTE WATER PROPERLY DISPOSED - Comments: OBSERVED FLOOR DRAIN OF FACILITY DRAINING INTO A LARGE BUCKET IN THE BASEMENT WITH A SUMP PUMP INSIDE THE BUCKET. MUST PROVIDE A PLUMBING AND DRAINAGE SYSTEM, APPROVED BY THE CHICAGO DEPARTMENT OF BUILDINGS, PLUMBING SECTOR. PRIORITY VIOLATION#: 7-38-030(C) NO CITATION ISSUED

Improper disposal contaminates environment and attracts pests.

All waste water must be properly disposed.

Discharge to approved sewer; No dumping outside; Grease trap maintained; No floor draining to exterior.

TOILET FACILITIES: PROPERLY CONSTRUCTED, SUPPLIED, & CLEANED - Comments: MUST PROVIDE SELF CLOSING DOOR FOR EMPLOYEE TOILET ROOM.

Inadequate facilities lead to poor hygiene and contamination.

Toilet rooms must be properly equipped and maintained.

Self-closing doors; Toilet paper; Covered waste receptacles; Handwashing supplies; Cleaned regularly; Proper ventilation.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: MUST SEAL ALL GAPS AND OPENINGS IN THE WALLS, FLOOR, AND CEILING IN THE FURNACE CLOSET, BY THE PIPING IN THE WALLS, AND IN THE BASEMENT.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: MUST REMOVE ALL UNUSED EQUIPMENT IN THE REAR PREP AREA. MUST REMOVE ALL CLUTTER AND UNNECESSARY ITEMS IN THE BASEMENT/HOT WATER TANK LOCATION; ORGANIZE, AND MAINTAIN AREAS.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: MUST PROVIDE A 4" FLOOR COVING IN PREP AREAS THAT IS A NON-POROUS, CORROSION-RESISTANT, SMOOTH, EASILY CLEANABLE SURFACE.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED RAW WOOD DOOR AND MOLDING AT THE FURNACE CLOSET AND. MUST PROVIDE A NON-POROUS, CORROSION-RESISTANT, SMOOTH, EASILY CLEANABLE SURFACE.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: MUST PROVIDE AN ADEQUATE VENTILATION HOOD FOR THE FOOD EQUIPMENT UNIT THAT IS USED TO PARTIAL COOK THE MAIZ/CORN

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: MUST REPLACE BROKEN LIGHT FIXTURE IN THE REAR PREP AREA

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: MUST REPLACE BROKEN LIGHT FIXTURE IN THE REAR PREP AREA

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.