EL RANCHITO FOOD MARKET Fails Health Inspection - Chicago Grocery store

FOOD PROTECTED DURING STORAGE, PREPARATION, DISPLAY, SERVICE AND TRANSPORTATION - Comments: All food should be properly protected from contamination during storage, preparation, display, service, and transportation. FOUND THE FOLLOWING ITEMS NOT PROTECTED FROM AIR, DUST, ELEMENTS AND HUMAN TOUCH. CHURROS, SMOKED PORK CHOPS, NOPALITOS ETC. MUST BE PROPERLY PROTECTED FOR HUMAN CONSUMPTIONS. PRODUCT REMOVED FROM SALE. SERIOUS VIOLATION 7-38-005(A) CITATION ISSUED. FOOD NOT PROTECTED.

Dirty equipment harbors and spreads pathogens, causing cross-contamination and illness.

All food contact surfaces must be properly cleaned and sanitized.

Wash, rinse, sanitize after each use; Clean between different raw foods; Every 4 hours for continuous use; When contaminated; Proper procedures and chemicals.

PREVIOUS MINOR VIOLATION(S) CORRECTED 7-42-090 - Comments: A separate and distinct offense shall be deemed to have been committed for each Minor violation that is not corrected upon re-inspection by the health authority. THE FOLLOWING PREVIOUS MINOR VIOLATIONS NOT CORRECTED AT THIS TIME FROM REPORT#166241 11-8-10: #34 FLOORS IN FURNACE ROOM NOT CLEAN, #35 HOLES IN WALLS NOT CORRECTED, #38 VENTS NOT CLEANED FULL OF DUST BUILD UP, #41 CLUTTER NOT REMOVED. ALL MUST BE CORRECTED AND MAINTAINED. SERIOUS VIOLATION 7-42-090 CITATION ISSUED PREVIOUS MINORS NOT CORRECTED.

Specialized processes without proper controls can create deadly toxins like botulism.

Special processes require approved HACCP plans or variances.

Written HACCP plan for: Vacuum packaging; Sous vide; Smoking for preservation; Curing; Using additives. Plan must be approved by CDPH.

This violation was corrected during the inspection.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: All food and non-food contact surfaces of equipment and all food storage utensils shall be thoroughly cleaned and sanitized daily. All utensils shall be thoroughly cleaned and sanitized after each usage. ALL EQUIPMENT IN NEED OF CLEANING TO REMOVE ALL FOOD BUILD-UP. MUST DEEP CLEAN AND MAINTAIN AT ALL TIMES.

Dirty equipment harbors bacteria and attracts pests.

All equipment and utensils must be clean and properly maintained.

Equipment clean to sight and touch; Free of food debris and grease; Maintained in good repair; Stored properly when clean.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: The floors shall be constructed per code, be smooth and easily cleaned, and be kept clean and in good repair. FLOORS UNDER AND AROUND ALL EQUIPMENT, FLOORS IN REAR PREP AREA, FRESH MEAT AREA NOT CLEAN. MUST DEEP CLEAN AND MAINTAIN AT ALL TIMES.

Damaged floors harbor bacteria and create safety hazards.

Floors must be smooth, cleanable, and maintained.

Smooth, non-porous in food areas; Properly sloped to drains; Coving at wall junctures; Kept clean; Good repair.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: The walls and ceilings shall be in good repair and easily cleaned. Use dustless cleaning methods. WALLS AND CEILING WITH PEELING PAINT AND FOOD SPLATTERS. LEAK AT CEILING IN REAR AREA AND SALES FLOOR. MUST CORRECT. MUST CLEAN AND REPAIR. MUST MAINTAIN AT ALL TIMES.

Damaged surfaces cannot be properly cleaned and may harbor pests.

Walls and ceilings must be smooth, cleanable, and in good repair.

Smooth, washable surfaces in food areas; Light colored; No holes or cracks; Clean and maintained.

LIGHTING: REQUIRED MINIMUM FOOT-CANDLES OF LIGHT PROVIDED, FIXTURES SHIELDED - Comments: All rooms in which food or drink is prepared, or in which utensils are washed, shall be lighted so that a minimum of 50-foot candles of light is available on all work surfaces. Shielding to protect against broken glass falling into food shall be provided for all artificial lighting sources in preparation, service, and display facilities. LIGHT SHEILDS IN NEED OF CLEANING, LIGHT SHEILDS IN NEED OF CLEANING. MUST CORRECT AND MAINTAIN AT ALL TIMES.

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

LIGHTING: REQUIRED MINIMUM FOOT-CANDLES OF LIGHT PROVIDED, FIXTURES SHIELDED - Comments: All rooms in which food or drink is prepared, or in which utensils are washed, shall be lighted so that a minimum of 50-foot candles of light is available on all work surfaces. Shielding to protect against broken glass falling into food shall be provided for all artificial lighting sources in preparation, service, and display facilities. LIGHT SHEILDS IN NEED OF CLEANING, LIGHT SHEILDS IN NEED OF CLEANING. MUST CORRECT AND MAINTAIN AT ALL TIMES.

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.