EL NOPAL BAKERY Fails Health Inspection - Chicago Bakery

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: OBSERVED NO EMPLOYEE HEALTH POLICY PROCEDURE.MUST PROVIDE AND MAINTAIN.(PRIORITY FOUNDATION -NO CITATION ISSUED)

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: OBSERVED NO CLEAN-UP POLICY PROCEDURE FOR VOMITING AND DIARRHEAL.MUST PROVIDE AND MAINTAIN.(PRIORITY FOUNDATION-NO CITATION ISSUED)

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: MUST INSTALL A HAND SINK WITH HOT AND COLD RUNNING WATER UNDER CITY PRESSURE CENTRALLY LOCATED IN PREP AREA AND MAINTAIN.(NO CITATION ISSUED

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

FOOD SEPARATED AND PROTECTED - Comments: OBSERVED NO SEPERATION OF ADJACENT DOOR TO SIDE STORAGE AREA .MUST SEAL OFF DOOR.

Improper storage allows contamination from dripping, pests, and cross-contamination between foods.

Food must be protected from contamination during storage and display.

Store 6 inches off floor; Cover all food; Separate raw from ready-to-eat; Proper storage order; Protect from overhead contamination; Use sneeze guards.

INSECTS, RODENTS, & ANIMALS NOT PRESENT - Comments: OBSERVED APPX. "1/2-1" GAP ALONG BOTTOM,SIDES,CENTERS OF FRONT AND BOTH REAR DOORS.MUST MAKE DOORS TIGHT FITTING TO PREVENT INSECT ENTRY.

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

INSECTS, RODENTS, & ANIMALS NOT PRESENT - Comments: OBSERVED EVIDENCE OF APPX.75 OR MORE RODENT ON FLOOR ON SALES FLOOR NEAR SHELVING UNIT AND LOWER WALL CABINETS,PREP AREA NEAR REAR DOOR NEXT TO OVEN,INSIDE ON LOWER LEDGE OF DOUGH MACHINE,TOOL STORAGE CABINET,IN SIDE STORAGE AREA ON FLOOR UNDER STORAGE RACK AND ON STORAGE RACK DISH SHELF.APPX.20 OR MORE LIVE LARGE FLIES FLYING AROUND PREMISES,ON WALLS AND CEILINGS.ALSO APPX. 10 OR MORE SMALL FLIES FLTING AROUND AND ON WALLS IN PREP AREA AND SIDE STORAGE AREA.MUST REMOVE DROPPINGS.CLEAN AND SANITIZE AREAS.RECOMMENDED TO HAVE A PEST CONTROL OPERATOR TO SERVICE PREMISES ON OR AFTER 7/26/18.(PRIORITY FOUNDATION NO CITATION ISSUED.

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: MUST APPLY A SEALANT OR PAINT RAW WOOD SHELF INSIDE OF COFFEE CABINET,METAL AND WOOD LOWER SHELVES OF PREP TABLES.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: MUST REPAIR OR REPLACE WORN DOOR GASKETS ON 3- DOOR REACH IN COOLER.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: MUST PROVIDE SINK STOPPERS FOR 3- COMPARTMENT SINK.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: MUST PROVIDE CHEMICAL TEST KIT AND MAINTAIN.

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

TOILET FACILITIES: PROPERLY CONSTRUCTED, SUPPLIED, & CLEANED - Comments: MUST PROVIDE A SELF CLOSING DEVICE ON TOILETROOM DOOR THAT LEADS INTO PREP AREA.

Inadequate facilities lead to poor hygiene and contamination.

Toilet rooms must be properly equipped and maintained.

Self-closing doors; Toilet paper; Covered waste receptacles; Handwashing supplies; Cleaned regularly; Proper ventilation.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: MUST SEAL GAP BETWEEN FLOOR AND WALL BEHIND PREP TABLE,GAP BETWEEN WALL BASE AND WALL UNDER MOPSINK.MUST REPAIR OR REPLACE LOOSE , MISSING AND DAMAGED WALLS AND TILES IN TOILETROOM AND PILLARS IN PREP AREA.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: MUST GROUT FLOOR IN PREP AREA.MUST SEAL HOLE IN FLOOR UNDER PREP TABLE.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: MUST PROVIDE VENTILATION IN TOILETROOM.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: MUST PROVIDE VENTILATION IN TOILETROOM.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.