EL BARCO RESTAURANT Fails Health Inspection - Chicago Restaurant

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: OBSERVED NO VERIFIABLE EMPLOYEE HEALTH POLICY ON SITE AT THE TIME OF INSPECTION. LEFT TEMPLATE AND INSTRUCTED TO MAINTAIN COPIES OF HEALTH POLICY SIGNED BY ALL EMPLOYEES ON SITE AT ALL TIMES. PRIORITY FOUNDATION VIOLATION 7-38-010. CITATION ISSUED.

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: OBSERVED NO KIT AND PROCEDURE FOR RESPONDING TO VOMIT AND DIARRHEA ON SITE AT THE INSPECTION. LEFT ONE PAGER AND INSTRUCTED TO MAINTAIN PROCEDURE AND KIT CONTAINING ALL NECESSARY SUPPLIES, INCLUDING A SANITIZER RATED AS EFFECTIVE AGAINST NOROVIRUS ON SITE AT ALL TIMES. PRIORITY FOUNDATION VIOLATION 7-38-005. CITATION ISSUED.

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: OBSERVED NO HANDWASHING SIGNAGE AT THE EXPOSED HANDWASHING SINK LOCATED AT THE BAR. INSTRUCTED TO PROVIDE.

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

FOOD-CONTACT SURFACES: CLEANED & SANITIZED - Comments: OBSERVED A HIGH-TEMPERATURE DISH MACHINE MAINTAINING AN IMPROPER FINAL RINSE TEMPERATURE OF 120F. THE MACHINE WAS TAGGED AND HELD FOR INSPECTION. INSTRUCTED TO REPAIR MACHINE SO THAT IT IS CAPABLE OF DELIVERING A FINAL RINSE TEMPERATURE BETWEEN 180-192F. PRIORITY VIOLATION 7-38-025. CITATION ISSUED.

Dirty equipment harbors and spreads pathogens, causing cross-contamination and illness.

All food contact surfaces must be properly cleaned and sanitized.

Wash, rinse, sanitize after each use; Clean between different raw foods; Every 4 hours for continuous use; When contaminated; Proper procedures and chemicals.

PROPER COLD HOLDING TEMPERATURES - Comments: OBSERVED THE FOLLOWING TCS ITEMS STORED IN THE PREP COOLER OPPOSITE THE COOK LINE, MAINTAINING THE STATED IMPROPER TEMPERATURES: FISH AT 47.8F AND CEVICHE AT 46.2F. MANAGEMENT VOLUNTARILY DISCARDED APPROXIMATELY 20 LBS OF PRODUCT VALUED AT APPROXIMATELY $400. INSTRUCTED TO MAINTAIN ALL TCS ITEMS AT OR BELOW 41F AT ALL TIMES. PRIORITY VIOLATION 7-38-005. CITATION ISSUED.

Temperatures below 135°F allow bacteria to multiply, especially spore-formers that survive cooking.

Hot foods must be held at 135°F or above.

Maintain 135°F or above; Check temperatures regularly; Proper hot holding equipment; Cannot reheat in hot holding units.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: OBSERVED NO IRREVERSIBLE REGISTERING THERMOMETER FOR CHECKING THE FINAL RINSE TEMPERATURE OF WATER IN THE HI-TEMP DISHMACHINE ON SITE AT THE TIME OF INSPECTION. INSTRUCTED TO PROVIDE. PRIORITY FOUNDATION VIOLATION 7-38-005. CITATION ISSUED.

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: OBSERVED SINK STOPPER EASTERN COMPARTMENT OF 3 COMPARTMENT SINK LOCATED IN THE REAR DISH AREA IS NOT WORKING. INSTRUCTED TO REPAIR OR REPLACE AND MAINTAIN IN GOOD CONDITION.

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: OBSERVED LEAK AT 3 COMPARTMENT SINK IN REAR DISH AREA AND HIGH TEMPERATURE DISH MACHINE LOCATED IN SAME AREA. INSTRUCTED TO REPAIR OR REPLACE AND MAINTAIN IN GOOD CONDITION.

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

ALL FOOD EMPLOYEES HAVE FOOD HANDLER TRAINING - Comments: OBSERVED ALL FOOD HANDLER CERTIFICATES ON SITE ARE EXPIRED. INSTRUCTED ALL FOOD EMPLOYEES MUST COMPLETE FOOD HANDLER TRAINING AND MAINTAIN RECORDS THEREOF ON SITE AT ALL TIMES.

Smoking contaminates hands and food with nicotine and tar residues.

Smoking prohibited in food establishments.

No smoking in any part of establishment; Designated areas away from food; Proper signage posted.

ALLERGEN TRAINING AS REQUIRED - Comments: OBSERVED NO ALLERGEN TRAINING CERTIFICATES ON SITE AT THE TIME OF INSPECTION. INSTRUCTED ALL EMPLOYEES HOLDING CITY OF CHICAGO FOODSERVICE MANAGER CERTIFICATE MUST COMPLETE ALLERGEN TRAINING AND MAINTAIN RECORDS THEREOF ON SITE AT ALL TIMES.

Inadequate allergen knowledge can cause life-threatening allergic reactions.

Food allergen training required for certified managers.

Certified managers must complete allergen training; Staff must understand major allergens; Prevent cross-contact; Respond to customer inquiries.

ALLERGEN TRAINING AS REQUIRED - Comments: OBSERVED NO ALLERGEN TRAINING CERTIFICATES ON SITE AT THE TIME OF INSPECTION. INSTRUCTED ALL EMPLOYEES HOLDING CITY OF CHICAGO FOODSERVICE MANAGER CERTIFICATE MUST COMPLETE ALLERGEN TRAINING AND MAINTAIN RECORDS THEREOF ON SITE AT ALL TIMES.

Inadequate allergen knowledge can cause life-threatening allergic reactions.

Food allergen training required for certified managers.

Certified managers must complete allergen training; Staff must understand major allergens; Prevent cross-contact; Respond to customer inquiries.