CHOP SUEY CITY CHICAGO INC. Gets Conditional Pass on Health Inspection - Chicago Restaurant

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: OBSERVED NO EMPLOYEE HEALTH POLICY ON SITE. INSTRUCTED TO PROVIDE.PRIORITY FOUNDATION VIOLATION. NO CITATION ISSUED.

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: OBSERVED NO CLEAN UP PROCEDURE FOR VOMIT AND DIARRHEAL EVENTS ON SITE. INSTRUCTED TO PROVIDE. NO CITATION ISSUED.

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: OBSERVED NO HAND WASHING SIGNAGE ON HAND SINK IN KITCHEN OR WASHBOWL SINKS IN RESTROOMS. INSTRUCTED TO PROVIDE.

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

FOOD-CONTACT SURFACES: CLEANED & SANITIZED - Comments: OBSERVED IMPROPER CLEANING PROCEDURE FOR UTENSILS. OBSERVED FOOD HANDLER BRUSH OFF UTENSIL USING STEEL WOOL, RINSE, THEN STORE ON DRYING RACK. INSTRUCTED MUST FOLLOW PROPER PROCEDURE FOR WASHING, RINSING AND SANITIZING ALL UTENSILS AND OR COOKING EQUIPMENT. DEMONSTRATED PROPER SET UP FOR 3 COMPARTMENT SINK WITH MANAGEMENT. OPERATOR WASHED, RINSED, AND SANITIZED ALL UTENSILS AND EQUIPMENT ON DRYING RACK DURING INSPECTION. MANAGER CORRECTED ON SITE. PRIORITY VIOLATION. 7-38-025. CITATION ISSUED.

Dirty equipment harbors and spreads pathogens, causing cross-contamination and illness.

All food contact surfaces must be properly cleaned and sanitized.

Wash, rinse, sanitize after each use; Clean between different raw foods; Every 4 hours for continuous use; When contaminated; Proper procedures and chemicals.

This violation was corrected during the inspection.

PROPER COLD HOLDING TEMPERATURES - Comments: OBSERVED THE FOLLOWING TCS FOODS AT IMPROPER TEMPERATURES IN COOLERS AND ON COUNTERS OF KITTCHEN: PORK @54.7, SHRIMP EGG ROLL MIX @50.0, SHRIMP EGG ROLLS @56.7, RAW EGGS @ 55.0, AND BEEF @84.2. MUST KEEP ALL TCS FOODS AT 41 DEGREES OR LOWER AT ALL TIMES. OPERATOR VOLUNTARILY DISCARDED 45LBS DENATURED FOODS DURING INSPECTION. OPERATOR ESTIMATES TOTAL COST OF DISCARDED FOOD TO BE $100. PRIORITY VIOLATION 7-38-005. CITATION ISSUED.

Temperatures below 135°F allow bacteria to multiply, especially spore-formers that survive cooking.

Hot foods must be held at 135°F or above.

Maintain 135°F or above; Check temperatures regularly; Proper hot holding equipment; Cannot reheat in hot holding units.

PROPER DATE MARKING AND DISPOSITION - Comments: OBSERVED TCS FOODS WITHOUT PROPER DISCARD DATE MARKING.INSTRUCTED TO PROVIDE.

Inadequate reheating fails to kill bacteria that grew during storage.

Foods must be reheated to 165°F within 2 hours.

Reheat to 165°F within 2 hours; Use proper equipment (not hot holding units); Discard if not reaching temperature in time.

THERMOMETERS PROVIDED & ACCURATE - Comments: OBSERVED NO THERMOMETERS IN ALL REFRIGERATORS. INSTRUCTED TO PROVIDE PROPERLY WORKING THERMOMETERS IN ALL REFRIGERATION UNITS.

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

INSECTS, RODENTS, & ANIMALS NOT PRESENT - Comments: OBSERVED GAP AT BOTTOM OF EXTERIOR DOOR IN REAR OF FACILITY. INSTRUCTED TO HAVE A TIGHT FITTING DOOR AND CLOSE GAP TO PREVENT PEST ENTRY.

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

WIPING CLOTHS: PROPERLY USED & STORED - Comments: OBSERVED WIPING CLOTHS STORED ON COUNTERS. INSTRUCTED MANAGER TO PROPERLY STORE WIPING CLOTHS IN SANITIZING SOLUTION.

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED EXCESSIVE DEBRIS ON FLOORS OF EMPLOYEE AND CUSTOMER RESTROOM. MUST DETAIL CLEAN AND MAINTAIN.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ALL FOOD EMPLOYEES HAVE FOOD HANDLER TRAINING - Comments: OBSERVED NO FOOD HANDLER TRAINING CERTIFICATES ON SITE. INSTRUCTED TO PROVIDE FOR ALL FOOD EMPLOYEES.

Smoking contaminates hands and food with nicotine and tar residues.

Smoking prohibited in food establishments.

No smoking in any part of establishment; Designated areas away from food; Proper signage posted.

ALL FOOD EMPLOYEES HAVE FOOD HANDLER TRAINING - Comments: OBSERVED NO FOOD HANDLER TRAINING CERTIFICATES ON SITE. INSTRUCTED TO PROVIDE FOR ALL FOOD EMPLOYEES.

Smoking contaminates hands and food with nicotine and tar residues.

Smoking prohibited in food establishments.

No smoking in any part of establishment; Designated areas away from food; Proper signage posted.