CHINA HUT Fails Health Inspection - Chicago Restaurant

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: OBSERVED NO EMPLOYEES HEALTH POLICY.MUST PROVIDE AND MAINTAIN.(PRIORITY FOUNDATION-7-38.010-NO CITATION ISSUED)

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: OBSERVED NO CLEAN-UP OF VOMITING AND DIARRHEA PROCEDURE AND CLEAN-UP KIT ON PREMISES DURING INSPECTION. INSTRUCTED TO HAVE SAID PROCEDURE ALONG WITH REQUIRED EQUIPMENT FOR CLEAN-UP. PRIORITY FOUNDATION VIOLATION. NO CITATION ISSUED. 7-38-005

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: OBSERVED NO HAND WASHING SOAP ON FRONT HAND WASHING SINK.PRIORITY FOUNDATION VIOLATION .MUST PROVIDE PROPER HAND WASHING SOAP AN ALL HAND WASHING SINKS.7-38-030 (C) CITATION ISSUED

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: OBSERVED THAT FOOD PREPARATION HAND WASHING SINK IS NOT FUNCTIONING PROPERLY AND IT DOESN'T HAVE PROPER HOT WATER REQUIREMENT FOR HAND WASHING. HOT WATER FAUCET IS BROKEN AND EMPLOYEE WHERE UNABLE TO OPEN AND CLOSE HOT WATER WHEN NEEDED.PRIORITY VIOLATION 7-38-030(C) CITATION ISSUED

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: OBSERVED THAT FRONT HAND WASHING SINK IS BLOCKED AND NOT ACCESSIBLE.MUST PROVIDE CLEAN AND ACCESSIBLE HAND WASHING SINK ALL TIME.PRIORITY FOUNDATION VIOLATION 7-38.030(C) COMBINED WITH PREVIOUS VIOLATION

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

PROPER DATE MARKING AND DISPOSITION - Comments: OBSERVED TCS FOODS ON SITE (SLICED TOMATOES,MARINATED BEEF,PRECOOKED CHICKEN AND PRECOOKED SHRIMP) WITH NO DATE MARKING STORED IN WALK IN COOLER. INSTRUCTED TO PROVIDE PROPER LABELING ON ALL TCS FOODS HELD FOR MORE THAN 24 HOURS WITH A 7 DAY DISCARD DATE. (PRIORITY VIOLATION NO CITATION ISSUED) 7-38-005

Inadequate reheating fails to kill bacteria that grew during storage.

Foods must be reheated to 165°F within 2 hours.

Reheat to 165°F within 2 hours; Use proper equipment (not hot holding units); Discard if not reaching temperature in time.

THERMOMETERS PROVIDED & ACCURATE - Comments: NOTED NO THERMOMETERS INSIDE REFRIGERATION UNIT CONSPICUOUSLY POSTED TO MONITOR THE AMBIENT TEMPERATURE OF EQUIPMENT. INSTRUCTED TO EQUIP ALL REFRIGERATION UNITS WITH ACCURATE AND WORKING THERMOMETERS

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

INSECTS, RODENTS, & ANIMALS NOT PRESENT - Comments: OBSERVED THAT PEST CONTROL LOG BOOK IS MISSING REQUIRED INFORMATION.MISSING COPY OF SERVICE TICKET THAT SETS FORTH PEST CONTROL IDPH LICENSE NUMBER. MUST PROVIDE AND MAINTAIN ALL REQUIRED PEST CONTROL RECORDS AND DOCUMENTS. PRIORITY FOUNDATION VIOLATION. 7-38.020 (C) CITATION ISSUED

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

CONTAMINATION PREVENTED DURING FOOD PREPARATION, STORAGE & DISPLAY - Comments: FOOD CONTAINERS STORED ON FLOOR IN PREP, STORAGE AND WALK-IN COOLER/FREEZERS. MUST PROVIDE PROPER, RAISED SHELVING TO STORE FOOD CONTAINERS 6" OFF FLOOR.

Contamination during preparation is a leading cause of foodborne illness.

Prevent contamination during all food handling.

Minimize bare hand contact; Prevent cross-contamination; Use clean equipment; Proper employee hygiene.

WIPING CLOTHS: PROPERLY USED & STORED - Comments: NOTED DIRTY WIPING CLOTHS ON PREP TABLES AT FRONT AND REAR PREP AREAS. NOT PROPERLY STORED. INSTRUCTED TO PROPERLY STORE ALL WASHCLOTHS IN A SANITIZING SOLUTION ESPECIALLY WHEN NOT IN USE

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.

IN-USE UTENSILS: PROPERLY STORED - Comments: OBSERVED THAT UTENSILS IN USE ARE STORED IN COLD WATER,MUST STORED UTENSILS UNDER RUNNING COLD WATER, UNDER HOT WATER (135 F AND ABOVE)AND IN CLEAN PLACE PROTECTED FROM CONTAMINATION.

Improper storage contaminates utensils between uses.

In-use utensils must be properly stored between uses.

Store in food with handle out; On clean surface; In running water; In water at 135°F or above.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: NOTED CARDBOARD BOXES USED TO LINE SHELVES. INSTRUCTED TO CLEAN AND REMOVE ALL CARDBOARD BOXES TO PREVENT HIDING PLACES FOR PEST.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED USE OF UNPROTECTED WOOD PALLETS IN WALK IN COOLER AS FOOD STORAGE SURFACE. MUST NOT USE UNPROTECTED WOOD AS FOOD CONTACT SURFACE , MUST PROVIDE PROPER SHELVING TO ELEVATE FOOD 6"ABOVE FLOOR

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: MUST REPAIR BROKEN GASKET ON DOOR TO WALK IN COOLER .

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: MAST CLEAN GASKETS ON DOORS TO WALK IN COOLERS COVERED WITH BLACK SLIMY SUBSTANCE

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: MUST CLEAN FOOD DEBRIS BUILD UP FROM FRYER CABINET,WHEEL BASES OF ALL EQUIPMENT.MUST CLEAN DUST BUILD UP FROM GLASS SHELVING UNITS IN FOOD STORAGE AREA.

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: MUST CLEAN DIRTY SHELVING IN WALK IN COOLER

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: BACKFLOW PREVENTION DEVICES NOT LOCATED AT ICE MACHINE . MUST INSTALL BACKFLOW PREVENTION DEVICES OR AIR GAP BETWEEN THE WATER SUPPLY INLET AND THE UNIT SO IT MAY BE LOCATED TO BE SERVICED AND MAINTAINED.

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

TOILET FACILITIES: PROPERLY CONSTRUCTED, SUPPLIED, & CLEANED - Comments: MUST PROVIDE TOILET ROOM RECEPTACLE WITH COVER FOR SANITARY NAPKINS IN UNISEX EMPLOYEE BATHROOM

Inadequate facilities lead to poor hygiene and contamination.

Toilet rooms must be properly equipped and maintained.

Self-closing doors; Toilet paper; Covered waste receptacles; Handwashing supplies; Cleaned regularly; Proper ventilation.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: NOTED CLUTTER OF EQUIPMENT AND OTHER UNUSED ITEMS ON FLOORS IN STORAGE ROOMS.MUST ELEVATE ALL ITEMS TO ALLOW CLEANING AND REMOVE ALL UNNECESSARY ITEMS.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: NOTED THE FOLLOWING:FLOORS THROUGHOUT PREMISE ESPECIALLY ALONG WALL BASE AND UNDERNEATH EQUIPMENT WITH DIRT, GREASE AND FOOD DEBRIS. WALLS WITH FOOD DIRT AND FOOD SPILLS. INSTRUCTED TO DETAIL CLEAN AND SANITIZE ESPECIALLY AREAS AROUND FOOD STORAGE AND COOKING AREA. CLEAN AND MAINTAIN WALLS WITH SPILLS. MUST UPGRADE HOUSEKEEPING.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: INSTRUCTED TO DETAIL CLEAN AND MAINTAIN ALL COOKING EQUIPMENT, INGREDIENT CONTAINERS, RACKS AND SHELVING WITH FLOUR, DUST, GREASE AND DIRT BUILD-UP THROUGHOUT.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ALL FOOD EMPLOYEES HAVE FOOD HANDLER TRAINING - Comments: OBSERVED NO FOOD HANDLER'S TRAINING CERTIFICATION FROM EMPLOYEE. INSTRUCTED THAT ALL EMPLOYEE'S MUST COMPLY WITH FOOD HANDLER'S TRAINING IN ACCORDANCE WITH THE FOOD HANDLING REGULATION ENFORCEMENT ACT.

Smoking contaminates hands and food with nicotine and tar residues.

Smoking prohibited in food establishments.

No smoking in any part of establishment; Designated areas away from food; Proper signage posted.

ALL FOOD EMPLOYEES HAVE FOOD HANDLER TRAINING - Comments: OBSERVED NO FOOD HANDLER'S TRAINING CERTIFICATION FROM EMPLOYEE. INSTRUCTED THAT ALL EMPLOYEE'S MUST COMPLY WITH FOOD HANDLER'S TRAINING IN ACCORDANCE WITH THE FOOD HANDLING REGULATION ENFORCEMENT ACT.

Smoking contaminates hands and food with nicotine and tar residues.

Smoking prohibited in food establishments.

No smoking in any part of establishment; Designated areas away from food; Proper signage posted.