CHICAGO PRODUCE Gets Conditional Pass on Health Inspection - Chicago Grocery store

HANDS WASHED AND CLEANED, GOOD HYGIENIC PRACTICES; NO BARE HAND CONTACT WITH READY-TO-EAT FOODS. - Comments: All employees who handle food shall wash their hands as often as necessary to maintain a high degree of personal cleanliness and should conform to hygienic practices prescribed by the Board of Health. OBSERVED EMPLOYEE AT THE BUTCHER AREA WASHING HIS HANDS INSIDE THE 3PART SINK WITH GLOVES ON. POOR HYGIENIC PRACTICES. INSTRUCTED HAND MUST BE WASHED IN THE EXPOSED SINK WITH WARM WATER AND SOAP AFTER REMOVING GLOVES/OR ANY CONTAMINATING CONDITION. THE WASHING OF HANDS INSIDE A UTENSIL-WASHING SINK IS PROHIBITED. CRITICAL CITATION ISSUED, 7-38-010(A).

Hands are #1 vehicle for pathogen transfer. Bare hand contact with ready-to-eat foods causes majority of foodborne outbreaks.

Proper handwashing and no bare hand contact with ready-to-eat foods.

Wash hands for 20 seconds with soap and warm water; Use utensils, deli tissue, or gloves for ready-to-eat foods; Wash hands after restroom, handling raw foods, touching face/hair, and between tasks.

SANITIZING RINSE FOR EQUIPMENT AND UTENSILS: CLEAN, PROPER TEMPERATURE, CONCENTRATION, EXPOSURE TIME - Comments: Equipment and utensils should get proper exposure to the sanitizing solution during the rinse cycle. Bactericidal treatment shall consist of exposure of all dish and utensil surfaces to a rinse of clean water at a temperature of not less than 180F. OBSERVED EMPLOYEE IN KITCHEN WASHING AND RINSING MULTI-USE UTENSILS AND PUTTING THEM TO DRY WITHOUT USING A SANITIZING METHOD. INSTRUCTED/DEMOSTRATED PROPER SET UP OF 3PART SINK FOR PROPER SANITATION. CRITICAL CITATION ISSUED, 7-38-030.

Improper sanitization fails to kill pathogens, allowing contaminated equipment to spread illness throughout facility.

Sanitizing solutions and rinse water must meet specific requirements for effectiveness.

Chemical sanitizers: Chlorine 50-100 ppm, Quaternary ammonium 200-400 ppm, Iodine 12.5-25 ppm; Hot water: 171°F for 30 seconds or 180°F at dish surface; Test strips required; Proper contact time.

FOOD AND NON-FOOD CONTACT SURFACES PROPERLY DESIGNED, CONSTRUCTED AND MAINTAINED - Comments: All food and non-food contact equipment and utensils shall be smooth, easily cleanable, and durable, and shall be in good repair. MUST SEAL ALL RAW/BARE WOOD SHELVES AT KITCHEN AND STORAGE AREAS, ALSO SEAL RUSTY SHELVES INSIDE THE GRINDING ROOM.

Unapproved processes may lack critical safety controls.

Variance required before conducting specialized food processes.

Submit application to CDPH; Include HACCP plan; Await approval before starting; Maintain all required records.

FOOD AND NON-FOOD CONTACT EQUIPMENT UTENSILS CLEAN, FREE OF ABRASIVE DETERGENTS - Comments: All utensils shall be thoroughly cleaned and sanitized after each usage. THE FOLLOWING NOT CLEAN, MUST CLEAN/SANITZE; COOLERS, FREEZERS, GRINDERS, SLICERS, GREASE TRAPS AND MOP SINK.

Dirty equipment harbors bacteria and attracts pests.

All equipment and utensils must be clean and properly maintained.

Equipment clean to sight and touch; Free of food debris and grease; Maintained in good repair; Stored properly when clean.

FLOORS: CONSTRUCTED PER CODE, CLEANED, GOOD REPAIR, COVING INSTALLED, DUST-LESS CLEANING METHODS USED - Comments: The floors shall be constructed per code, be smooth and easily cleaned, and be kept clean and in good repair. MUST CLEAN FLOORS THRU-OUT, UNDER, BEHIND EQUIPMENT AND PALLETS AT CORNERS AND ALONG WALLS.

Damaged floors harbor bacteria and create safety hazards.

Floors must be smooth, cleanable, and maintained.

Smooth, non-porous in food areas; Properly sloped to drains; Coving at wall junctures; Kept clean; Good repair.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: The walls and ceilings shall be in good repair and easily cleaned. MUST CLEAN HOOD AND FILTER ABOVE COOKING EQUIPMENT IN KITCHEN, REPAIR WALLS AND REPAINT INSIDE RAW CHICKEN STORAGE WALK IN COOLER AND WOMENS WASHROOM AND REPLACE DAMAGED CEILING PANELS IN KITCHEN.

Damaged surfaces cannot be properly cleaned and may harbor pests.

Walls and ceilings must be smooth, cleanable, and in good repair.

Smooth, washable surfaces in food areas; Light colored; No holes or cracks; Clean and maintained.

WALLS, CEILINGS, ATTACHED EQUIPMENT CONSTRUCTED PER CODE: GOOD REPAIR, SURFACES CLEAN AND DUST-LESS CLEANING METHODS - Comments: The walls and ceilings shall be in good repair and easily cleaned. MUST CLEAN HOOD AND FILTER ABOVE COOKING EQUIPMENT IN KITCHEN, REPAIR WALLS AND REPAINT INSIDE RAW CHICKEN STORAGE WALK IN COOLER AND WOMENS WASHROOM AND REPLACE DAMAGED CEILING PANELS IN KITCHEN.

Damaged surfaces cannot be properly cleaned and may harbor pests.

Walls and ceilings must be smooth, cleanable, and in good repair.

Smooth, washable surfaces in food areas; Light colored; No holes or cracks; Clean and maintained.