CHICAGO LIVE POULTRY Fails Health Inspection - Chicago Live poultry

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: A SIGN OR POSTER THAT NOTIFIES FOOD EMPLOYEES TO WASH THEIR HANDS NOT PROVIDED ON EXPOSED HAND WASHING SINKS.SIGNS SHALL BE PROVIDED AT ALL HANDSHAKING SINKS USED BY FOOD EMPLOYEES

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

PROPER COLD HOLDING TEMPERATURES - Comments: OBSERVED IMPROPER TEMPERATURES OF POULTRY MEAT AT 80.5 F STORED ON ROOM TEMPERATURE IN PREP AREA.PRODUCT WAS NOT DISCARDED BY MANAGER IT WAS GIVEN TO CUSTOMER AFTER FACILITY NOTIFIED OF IMPROPER HOLDING TEMPERATURE. MUST HAVE COLD HOLDING FOODS AT 41.0 F OR BELOW.(PRIORITY 7-38-005) NO CITATION ISSUED

Temperatures below 135°F allow bacteria to multiply, especially spore-formers that survive cooking.

Hot foods must be held at 135°F or above.

Maintain 135°F or above; Check temperatures regularly; Proper hot holding equipment; Cannot reheat in hot holding units.

PROPER COOLING METHODS USED; ADEQUATE EQUIPMENT FOR TEMPERATURE CONTROL - Comments: OBSERVED IMPROPER TEMPERATURE SLAUGHTERED CHICKEN OF 80.5 F STORED ON ROOM TEMPERATURE. OBSERVED THAT FACILITY DOESNT HAVE ANY COOLING UNIT TO KEEP SLAUGHTERED ANIMALS REFRIGERATED AFTER SLAUGHTERING PROCESS TILL THEY ARE PICKED UP BUY CUSTOMERS.PRIORITY 7-38-005 NO CITATION ISSUED

Dirty equipment harbors bacteria and attracts pests.

All equipment and utensils must be clean and properly maintained.

Equipment clean to sight and touch; Free of food debris and grease; Maintained in good repair; Stored properly when clean.

THERMOMETERS PROVIDED & ACCURATE - Comments: OBSERVED NO PROBE THERMOMETER FOR TAKING FOOD TEMPERATURES.MUST PROVIDE.(PRIORITY FOUNDATION-NO CITATION ISSUED) 7-38-005

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

INSECTS, RODENTS, & ANIMALS NOT PRESENT - Comments: OBSERVED APPROXIMATELY 2 INCH BY 1/2 INCH OPENING UNDER REAR EXIT DOOR.MAKE DOOR TIGHT FITTING.

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

INSECTS, RODENTS, & ANIMALS NOT PRESENT - Comments: NOTED OVER 15-20 MICE DROPPING ON FLOORS AT REAR STORAGE AREA AND. INSTRUCTED TO CLEAN AND SANITIZE AFFECTED AREAS. RECOMMENDED TO CONSULT WITH PEST CONTROL COMPANY. MUST ALSO ELIMINATE THE FLYING INSECT PROBLEM AND PEST CONTROL UPON BEING RE-INSPECTED. PRIORITY FOUNDATION #7-38-020(A).

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: CUTTING BOARDS WITH OPEN SEAMS AND DARK STAINS. MUST REFINISH OR REPLACE DAMAGED OR STAINED CUTTING BOARDS

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: MUST CLEAN AND MAINTAIN CLEAN INTERIOR AND EXTERIOR OF REACH OVER FREEZER

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: MUST CLEAN AND MAINTAIN CLEAN INTERIOR OF REFRIGERATOR EGGS STORAGE UNIT

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: MUST CLEAN AND MAINTAIN CLEAN SHELVING AND LIVE CHICKEN STORAGE

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: MUST REPAIR LEAK FROM HAND WASHING SINK LOCATED IN BACK ROOM

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

SEWAGE & WASTE WATER PROPERLY DISPOSED - Comments: OBSERVED THREE COMPARTMENT SINK IN SLAUGHTER AREA IN DISREPAIR NOT DRAINING PROPERLY AND LEAKING FROM GREASE TRAP UNDER NEATH OF SINK. INFORMED PERSON IN CHARGE OF REQUIREMENTS AND MUST REPAIR SINK AND MAINTAIN. PRIORITY VIOLATION 7-38-030(C) NO CITATION ISSUED.

Improper disposal contaminates environment and attracts pests.

All waste water must be properly disposed.

Discharge to approved sewer; No dumping outside; Grease trap maintained; No floor draining to exterior.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED THAT FLOORS IN MAIN MEAT PREP ROOM IS NOT SMOOTH EASY CLEANABLE. MUST REPAIR AND MAINTAIN

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: MUST DETAIL CLEAN THE FLOOR ALONG THE WALL BASE,ALL CORNER THRU-OUT THE ESTABLISHMENT AND MAINTAIN. WALLS AND DOORS, IN THE PREP AREA AND REAR AREA WITH DUST,CHICKEN FEATHERS AND BLOOD STAINED. INSTRUCTED TO DETAIL CLEAN ,SANITIZE AND MAINTAIN. CEILING VENT COVER THRU-OUT WITH DUST BUILD-UP. INSTRUCTED TO DETAIL CLEAN AND MAINTAIN.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: OBSERVED THAT VENTILATION SYSTEM DUCKS AND OPENINGS ARE COVERED WITH DUST MUST CLEAN AND MAINTAIN CLEAN .ALL VENTILATION SYSTEM

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: OBSERVED THAT VENTILATION SYSTEM DUCKS AND OPENINGS ARE COVERED WITH DUST MUST CLEAN AND MAINTAIN CLEAN .ALL VENTILATION SYSTEM

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.