BIG RAYS GRILL, INC. Fails Health Inspection - Chicago Restaurant

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: NO EMPLOYEE HEALTH POLICY ON SITE AT THE TIME OF INSPECTION. INSTRUCTED TO OBTAIN AND MAINTAIN. PRIORITY FOUNDATION #7-38-010

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: NO VOMIT OR DIARRHEA PROCEDURE ON SITE AT TIME OF INSPECTION. INSTRUCTED TO OBTAIN AND NO CITATION ISSUED MAINTAIN. PRIORITY FOUNDATION #7-38-005

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

HANDS CLEAN & PROPERLY WASHED - Comments: OBSERVED FOOD HANDLER WASHING HIS HANDS IN THE 3 COMPARTMENT SINK AND DRYING THEM ON A SOILED TOWEL. FOOD EMPLOYEES SHALL CLEAN THEIR HANDS IN A HANDWASHING SINK OR APPROVED AUTOMATIC HANDWASHING FACILITY AND AY NOT CLEAN THEIR HANDS IN A SINK USED FOR FOOD PREPARATION OR WAREWASHING. PRIORITY FOUNDATION VIOLATION 7-38-010

Improper sanitization fails to kill pathogens, allowing contaminated equipment to spread illness throughout facility.

Sanitizing solutions and rinse water must meet specific requirements for effectiveness.

Chemical sanitizers: Chlorine 50-100 ppm, Quaternary ammonium 200-400 ppm, Iodine 12.5-25 ppm; Hot water: 171°F for 30 seconds or 180°F at dish surface; Test strips required; Proper contact time.

NO BARE HAND CONTACT WITH RTE FOOD OR A PRE-APPROVED ALTERNATIVE PROCEDURE PROPERLY ALLOWED - Comments: OBSERVED FOOD HANDLER USING HIS BARE HANDS WITHOUT GLOVES WHILE APPLYING TOMATO AND LETTUCE(READY TO EAT FOOD) TO A BURGER. FOOD EMPLOYEES MAY NOT CONTACT EXPOSED, READY TO EAT FOOD WITH THEIR BARE HANDS AND SHALL USE SUITABLE UTENSILS SUCH AS DELI TISSUE, SPATULAS, TONGS, SINGLE USE GLOVES, OR DISPENSING EQUIPMENT . PRIORITY VIOLATION 7-38-010

Contaminated water spreads waterborne diseases. Insufficient hot water prevents proper sanitization.

Potable water supply must be adequate, protected, and properly heated.

Water from approved public system; Sufficient pressure for all operations; Hot water minimum 120°F at fixtures, 180°F for high-temp dishwashers; Backflow prevention installed; No cross-connections.

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: FOUND NO HAND WASH SINK IN THE FRONT PREP AREA. INSTRUCTED TO INSTALL AND MAINTAIN. PRIORITY FOUNDATION VIOLATION 7-38-030(c)

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

FOOD-CONTACT SURFACES: CLEANED & SANITIZED - Comments: OBSERVED INSIDE OF ICE MACHINE LOCATED IN THE REAR PREP AREA AND THE FRONT PREP AREA WITH A PINK SLIMY SUBSTANCE. INSTRUCTED TO EMPTY, CLEAN, SANITIZE AND MAINTAIN

Dirty equipment harbors and spreads pathogens, causing cross-contamination and illness.

All food contact surfaces must be properly cleaned and sanitized.

Wash, rinse, sanitize after each use; Clean between different raw foods; Every 4 hours for continuous use; When contaminated; Proper procedures and chemicals.

PROPER HOT HOLDING TEMPERATURES - Comments: OBSERVED CHICKEN GYRO(49F) AND GYRO MEAT(49.9) HELD AT IMPROPER TEMPERATURES. TIME/TEMPERATURE CONTROL FOR SAFETY FOOD SHALL BE MAINTAINED AT 135F OR ABOVE. MANAGER VOLUNTARILY DISCARDED 23LBS VALUED AT $90. PRIORITY VIOLATION 7-38-005

Temperatures above 41°F allow rapid bacterial multiplication, doubling every 20 minutes.

Cold foods must be held at 41°F or below.

Maintain 41°F or below; Check temperatures regularly; Properly functioning refrigeration; Thermometers in all units; Keep doors closed.

PROPER DATE MARKING AND DISPOSITION - Comments: VARIETY OF FOODS NOT PROPERLY LABELED (HOT DOGS, GYRO SAUCE, CUT TOMATOES,CHICKEN , ETC.) STORED INSIDE FRONT PREP REACH IN COOLER. FOOD PREPARED AND HELD FOR MORE THAN 24 HOURS SHALL BE PROPERLY LABELED TO INDICATE THE DAY OR DATE IN WHICH THE FOOD SHALL BE DISCARDED. PRIORITY FOUNDATION VIOLATION 7-38-005

Inadequate reheating fails to kill bacteria that grew during storage.

Foods must be reheated to 165°F within 2 hours.

Reheat to 165°F within 2 hours; Use proper equipment (not hot holding units); Discard if not reaching temperature in time.

CONSUMER ADVISORY PROVIDED FOR RAW/UNDERCOOKED FOOD - Comments: NOTED ESTABLISHMENT SERVING UNDERCOOKED FOOD ITEMS (HAMBURGERS) WITH NO CONSUMER ADVISORY, DISCLOSURE OR REMINDERS TO THE CUSTOMERS. INSTRUCTED TO HAVE A CONSUMER ADVISORY ON THE MENU WITH A DISCLOSURE NOTICE AND REMINDER STATEMENT. PRIORITY FOUNDATION #7-38-005.

Dirty surfaces attract pests and can contaminate food indirectly.

Non-food contact surfaces must be kept clean.

Clean as often as necessary; Remove grease and debris; Maintain equipment exteriors; Keep walls, ceilings, floors clean.

WIPING CLOTHS: PROPERLY USED & STORED - Comments: OBSERVED WIPING CLOTHS THAT WERE SOILED AND NOT STORED IN SANITIZING SOLUTION. INSTRUCTED TO PROVIDE AND MAINTAIN

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: OBSERVED CARD BOARD BEING USED AS SHELF LINER. INSTRUCTED TO REMOVE AND MAINTAIN

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

WAREWASHING FACILITIES: INSTALLED, MAINTAINED & USED; TEST STRIPS - Comments: FOUND NO SANITIZING SOLUTION TESTING DEVICES. A TEST KIT OR OTHER DEVICE THAT ACCURATELY MEASURES THE CONCENTRATION IN MG/L OF SANITIZING SOLUTIONS SHALL BE PROVIDED. PRIORITY FOUNDATION VIOLATION 7-38-005

Cannot verify sanitization without test strips, risking contaminated equipment.

Warewashing facilities must be properly equipped and supplied.

3-compartment sink or dishwasher; Test strips for sanitizer; Thermometers for water temperature; Adequate drainboards; Proper detergents.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: OBSERVED THE GRILL, FRYER, ETC WITH GREASE BUILD UP. INSTRUCTED TO CLEAN AND MAINTAIN

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: FOUND NO BACK FLOW PREVENTION DEVICE ON THE MOP SINK. INSTRUCTED TO PROVIDE AND MAINTAIN

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: OBSERVED UNNECESSARY ITEMS SUCH AS TOOLS, PERSONAL ITEMS, UNUSED EQUIPMENT, ETC. INSTRUCTED TO ORGANIZE AND MAINTAIN

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: FOUND NON SHATTER PROOF BULBS IN THE REAR PREP/DISH WASHING AREA. INSTRUCTED TO PROVIDE AND MAINTAIN FOUND LIGHT BULBS MISSING THROUGHOUT THE FACILITY. INSTRUCTED TO PROVIDE AND MAINTAIN

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: FOUND NON SHATTER PROOF BULBS IN THE REAR PREP/DISH WASHING AREA. INSTRUCTED TO PROVIDE AND MAINTAIN FOUND LIGHT BULBS MISSING THROUGHOUT THE FACILITY. INSTRUCTED TO PROVIDE AND MAINTAIN

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.