1492 CUBAN FUSION INC Fails Health Inspection - Chicago Restaurant

MANAGEMENT, FOOD EMPLOYEE AND CONDITIONAL EMPLOYEE; KNOWLEDGE, RESPONSIBILITIES AND REPORTING - Comments: Inspector Comments: Violation Codes: 2-102.14(N) Inspector Comments: OBSERVED NO SIGNED EMPLOYEES HEALTH POLICIES.MUST PROVIDE AND MAINTAIN.(PRIORITY FOUNDATION-NO CITATION ISSUED)

Ill food workers cause 70% of foodborne outbreaks. Proper reporting prevents transmission of Norovirus, Hepatitis A, Salmonella, and other serious diseases.

All food employees must understand and follow health reporting requirements and food safety responsibilities.

Employees must: Report illness symptoms and exposures; Be excluded/restricted when ill; Understand their role in preventing foodborne illness; Follow proper hygiene practices; Have signed health policy on file.

PROCEDURES FOR RESPONDING TO VOMITING AND DIARRHEAL EVENTS - Comments: Inspector Comments: Violation Codes: 2-501.11 Inspector Comments: OBSERVED NO CLEAN-UP POLICY PROCEDURE AND ITEMS FOR VOMITING AND DIARRHEA.MUST PROVIDE AND MAINTAIN.(PRIORITY FOUNDATION- NO CITATION ISSUED)

Vomit and diarrhea contain millions of viral particles. One incident can contaminate entire facility and cause outbreak affecting dozens.

Written procedures required for cleaning bodily fluid events to prevent disease transmission.

Written procedure must address: Isolating contaminated area; Removing and discarding affected food; Using proper PPE; Cleaning and sanitizing with appropriate concentration; Proper disposal of contaminated materials.

ADEQUATE HANDWASHING SINKS PROPERLY SUPPLIED AND ACCESSIBLE - Comments: OBSERVED NO SOAP AT HAND WASHING SINK IN MAIN PREP AREA.MUST PROVIDE AND MAINTAIN SOAP AT ALL TIMES AT ALL HAND SINKS.SOAP WAS PROVIDED DURING INSPECTION.(COS)(PRIORITY FOUNDATION 7-38-030(C)

Blocked or unsupplied sinks force employees to skip handwashing, spreading fecal bacteria and viruses to food.

Handwashing sinks must be accessible, properly supplied, and used only for handwashing.

Each sink needs: Warm water (100°F minimum); Soap in dispensers; Paper towels or air dryers; Waste receptacles; Signage; Clear access; Used only for handwashing.

PROPER HOT HOLDING TEMPERATURES - Comments: OBSERVED IMPROPER TEMPERATURES OF 3LBS. COOKED PORK 93.0F ON TOP OF PREP COOLER AND 2LBS. COOKED ONIONS 75.2F INSIDE A PAN ON STOVE.MUST HAVE HOT HOLDING FOODS AT 135.0F OR ABOVE. PRODUCT WAS DISCARDED BY MANAGER.APPX.5LBS.$10.(PRIORITY 7-38-005)

Temperatures above 41°F allow rapid bacterial multiplication, doubling every 20 minutes.

Cold foods must be held at 41°F or below.

Maintain 41°F or below; Check temperatures regularly; Properly functioning refrigeration; Thermometers in all units; Keep doors closed.

PROPER COLD HOLDING TEMPERATURES - Comments: OBSERVED IMPROPER TEMPERATURES OF COLD HOLDING FOODS INSIDE OF WALK IN COOLER SUCH AS 12LBS. COOKED SPANISH RICE 45.0F,45.7F,48.0F,48.4F.16LBS. COOKED BEEF 44.6F,45.3F,45.9F,46.9F.2LBS. COOKED ONIONS 47.1F.6LBS. DATED 7/24/19 COOKED RICE & BEANS -44.6F-44.8F DATED 7/20/19.12LBS. COOKED BLACK BEANS-45.7F,46.0F,46.4F,47.7F,49.5F DATED 7/24/19.PRODUCT WAS DISCARDED BY MANAGER.MUST HAVE COLD HOLDING FOODS AT 41.0F OR BELOW.APPX.48LBS. $111.(PRIORITY)CONSOLIDATED VIOLATION.

Temperatures below 135°F allow bacteria to multiply, especially spore-formers that survive cooking.

Hot foods must be held at 135°F or above.

Maintain 135°F or above; Check temperatures regularly; Proper hot holding equipment; Cannot reheat in hot holding units.

PROPER DATE MARKING AND DISPOSITION - Comments: Inspector Comments: Violation Codes: 3-501.17 Inspector Comments: OBSERVED NO DATE MARKINGS ON TCS READY TO EAT FOODS BEING HELD IN COOLERS FOR MORE THAN 24 HOURS.MUST PROVIDE AND MAINTAIN.(PRIORITY FOUNDATION-NO CITATION ISSUED

Inadequate reheating fails to kill bacteria that grew during storage.

Foods must be reheated to 165°F within 2 hours.

Reheat to 165°F within 2 hours; Use proper equipment (not hot holding units); Discard if not reaching temperature in time.

CONSUMER ADVISORY PROVIDED FOR RAW/UNDERCOOKED FOOD - Comments: Inspector Comments: Violation Codes: 3-603.11 Inspector Comments: OBSERVED NO CONSUMER ADVISORY DISCLOSURE AND REMINDER OF RISK OF CONSUMING RAW AND UNDERCOOKED FOODS ON MENU.MUST PORVIDE AND MAINTAIN.(PRIORITY FOUNDATION-NO CITATION ISSUED)

Dirty surfaces attract pests and can contaminate food indirectly.

Non-food contact surfaces must be kept clean.

Clean as often as necessary; Remove grease and debris; Maintain equipment exteriors; Keep walls, ceilings, floors clean.

THERMOMETERS PROVIDED & ACCURATE - Comments: OBSERVED NO THERMOMETER FOR 3- DOOR PREP COOLER AND 2- DOOR PREP IN REAR HALLWAY.MUST PROVIDE.

Inadequate lighting prevents detection of contamination and pests.

Adequate protected lighting required in all areas.

50 foot-candles at prep surfaces; 20 foot-candles at 30 inches in storage; Shielded bulbs over exposed food; Clean fixtures.

FOOD PROPERLY LABELED; ORIGINAL CONTAINER - Comments: Inspector Comments: Violation Codes: 3-302.12 Inspector Comments: MUST LABEL FOOD STORAGE CONTAINERS WHEN FOOD IS NOT IN ORIGINAL PACKAGE

Missing allergen labeling can cause severe allergic reactions.

All food properly labeled with required information.

Common name; Ingredients; Allergen declarations; Date marking; Manufacturer info; Net quantity.

INSECTS, RODENTS, & ANIMALS NOT PRESENT - Comments: Inspector Comments: Violation Codes: 6-202.15 Inspector Comments: OBSERVED AN APPX."1/2-3/4" GAP ALONG BOTTOM OF ENTRY DOOR .MUST MAKE DOOR TIGHT FITTING

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

INSECTS, RODENTS, & ANIMALS NOT PRESENT - Comments: OBSERVED EVIDENCE OF APPX. 10- 12 LIVE LARGE FLIES AND APPX. 4-6 SMALL FLIES FLYING AROUND IN BASEMENT FOOD & PAPER ,SUMP PUMP AREA,STORAGE AREAS.RECOMMENDED TO HAVE A PEST CONTROL OPERATOR TO SERVICE PREMISES ON OR AFTER 7/25/19.(PRIORITY FOUNDATION 7-38-020(A)

Pests spread numerous diseases through contamination.

No pests or animals allowed in facility.

No evidence of pests; No live animals except service animals; Effective pest control program.

WIPING CLOTHS: PROPERLY USED & STORED - Comments: Inspector Comments: Violation Codes: 3-304.14 Inspector Comments: MUST STORE WIPING CLOTHS IN A SANITIZING SOLUTIION WHEN NOT IN USE

Contaminated cloths spread bacteria across multiple surfaces.

Wiping cloths must be properly sanitized and stored.

Store in sanitizer between uses (200ppm quat or 50-100ppm chlorine); Separate cloths for food and non-food surfaces; Test sanitizer concentration.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: MUST REMOVE FOIL WRAPPED AROUND STOVE AND RUST FROM LOWER SHELVES OF PREP TABLES.

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

FOOD & NON-FOOD CONTACT SURFACES CLEANABLE, PROPERLY DESIGNED, CONSTRUCTED & USED - Comments: Inspector Comments: Violation Codes: 4-501.11 Inspector Comments: MUST REPAIR OR REPLACE WORN DOOR GASKETS ON 3- DOOR PREP COOLER.MUST PROVIDE A LOCK FOR EACH REFRIGERATOR STORED OUTSIDE OF TOILET ROOMS AND NEAR REAR DOOR

Poor design creates areas that harbor bacteria.

All surfaces must be designed to be easily cleanable.

Smooth, non-porous surfaces; Free of cracks and crevices; Easily disassembled; Accessible for cleaning.

NON-FOOD/FOOD CONTACT SURFACES CLEAN - Comments: MUST CLEAN DEBRIS BUILD UP FROM GRILL TABLES,PREP COOLER,FRYER CABINET,WALK IN COOLER FAN GUARD COVER AND SHELVING UNITS.

Accumulated soil attracts pests and harbors bacteria.

All surfaces must be kept clean.

Clean equipment interiors and exteriors; Walls, ceilings, floors clean; Remove grease and debris; Clean as often as necessary.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: MUST REPAIR OR REPLACE SLOW DRAIN AT HAND SINK IN WOMEN'S TOILET ROOM.

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

PLUMBING INSTALLED; PROPER BACKFLOW DEVICES - Comments: Inspector Comments: Violation Codes: 4-301.16 Inspector Comments: MUST PROVIDE A DUMP SINK TO DISCARD LIQUID WASTE IN FRONT BEVERAGE / COFFEE AREA

Backflow can contaminate entire water supply with sewage or chemicals.

Plumbing must be properly installed with backflow prevention.

Air gaps at fixtures; Backflow preventers on connections; No cross-connections; Annual testing of devices; Proper drainage.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: Inspector Comments: Violation Codes: 6-201.13 Inspector Comments: MUST REPAIR OR REPLACE BROKEN/DAMAGED CONCRETE FLOOR AND WALL IN BASEMENT

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: Inspector Comments: Violation Codes: 6-201.16 Inspector Comments: MUST SCRAPE AND PAINT PEELING PAINT ON WALLS IN DINING AREA AND OUTSIDE OF TOILETROOMS

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: Inspector Comments: Violation Codes: 6-501.13 Inspector Comments: MUST CLEAN DEBRIS FROM FLOOR IN BETWEEN COOLERS AND IN BASEMENT

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

PHYSICAL FACILITIES INSTALLED, MAINTAINED & CLEAN - Comments: MUST REPLACE STAINED CEILING TILES IN REAR PREP AREA.

Deteriorated facilities harbor pests and prevent proper cleaning.

Building must be maintained in good condition.

No holes in walls/ceilings; Doors and windows intact; Fixtures functional; No water damage; Surfaces intact.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: MUST CLEAN DEBRIS BUILD UP ON FILTERS AND HOOD AT COOKING EQUIPMENT.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.

ADEQUATE VENTILATION & LIGHTING; DESIGNATED AREAS USED - Comments: MUST CLEAN DEBRIS BUILD UP ON FILTERS AND HOOD AT COOKING EQUIPMENT.

Poor ventilation causes condensation and grease buildup; inadequate lighting hides contamination.

Proper ventilation and lighting required throughout.

Ventilation prevents condensation; Adequate lighting for operations; Fixtures shielded; Hoods over cooking equipment.